高校化学工程学报
高校化學工程學報
고교화학공정학보
JOURNAL OF CHEMICAL ENGINEERING OF CHINESE UNIVERSITIES
2007年
2期
189-193
,共5页
韩一松%任其龙%杨亦文%张海%吴平东
韓一鬆%任其龍%楊亦文%張海%吳平東
한일송%임기룡%양역문%장해%오평동
超临界流体色谱(SFC)%二十碳五烯酸乙酯(EPA-EE)%二十二碳六烯酸乙酯(DHA-EE)%色谱效能
超臨界流體色譜(SFC)%二十碳五烯痠乙酯(EPA-EE)%二十二碳六烯痠乙酯(DHA-EE)%色譜效能
초림계류체색보(SFC)%이십탄오희산을지(EPA-EE)%이십이탄륙희산을지(DHA-EE)%색보효능
以超临界CO2为流动相ODS-C18为固定相,以尿素包络法处理后的鱼油乙酯化物为原料,柱温为55℃,柱前压为12.1 Mpa,改变载量和流动相流速,测定了二十碳五烯酸乙酯(EPA-EE)和二十二碳六烯酸乙酯(DHA-EE)的色谱动态特性.结果表明,EPA-EE与DHA-EE之间的分离良好,但原料中其他脂肪酸乙酯杂质不能分离.适当切割流出物馏分,EPA-EE的纯度可达90%,DHA-EE可达75%.根据实验结果考察了载量和流动相流速对制备色谱效能的影响.色谱柱的生产能力随流速的增大而增大.在EPA-EE纯度一定的前提下,色谱柱的生产能力随载量的增大而增大,但载量过大则生产能力又会减小.当EPA-EE纯度要求在85%以下时,载量对其回收率的影响不大,CO2消耗量(每单位重量产品的消耗)随着载量的增大而减少;纯度要求在90%以上时,回收率随载量的增大而明显减小,CO2消耗量随载量的变化有最低点,在载量为4.076 mL·L-1时为最小.EPA-EE纯度要求为90%时,适宜载量为7.13 mL·L-1,流动相流速为3.928 g·min-1,此时色谱柱的生产能力为2.41 g·h-1·L-1,EPA-EE回收率为37.8%.同时得到的DHA-EE的纯度为75%,回收率为88.8%.
以超臨界CO2為流動相ODS-C18為固定相,以尿素包絡法處理後的魚油乙酯化物為原料,柱溫為55℃,柱前壓為12.1 Mpa,改變載量和流動相流速,測定瞭二十碳五烯痠乙酯(EPA-EE)和二十二碳六烯痠乙酯(DHA-EE)的色譜動態特性.結果錶明,EPA-EE與DHA-EE之間的分離良好,但原料中其他脂肪痠乙酯雜質不能分離.適噹切割流齣物餾分,EPA-EE的純度可達90%,DHA-EE可達75%.根據實驗結果攷察瞭載量和流動相流速對製備色譜效能的影響.色譜柱的生產能力隨流速的增大而增大.在EPA-EE純度一定的前提下,色譜柱的生產能力隨載量的增大而增大,但載量過大則生產能力又會減小.噹EPA-EE純度要求在85%以下時,載量對其迴收率的影響不大,CO2消耗量(每單位重量產品的消耗)隨著載量的增大而減少;純度要求在90%以上時,迴收率隨載量的增大而明顯減小,CO2消耗量隨載量的變化有最低點,在載量為4.076 mL·L-1時為最小.EPA-EE純度要求為90%時,適宜載量為7.13 mL·L-1,流動相流速為3.928 g·min-1,此時色譜柱的生產能力為2.41 g·h-1·L-1,EPA-EE迴收率為37.8%.同時得到的DHA-EE的純度為75%,迴收率為88.8%.
이초림계CO2위류동상ODS-C18위고정상,이뇨소포락법처리후적어유을지화물위원료,주온위55℃,주전압위12.1 Mpa,개변재량화류동상류속,측정료이십탄오희산을지(EPA-EE)화이십이탄륙희산을지(DHA-EE)적색보동태특성.결과표명,EPA-EE여DHA-EE지간적분리량호,단원료중기타지방산을지잡질불능분리.괄당절할류출물류분,EPA-EE적순도가체90%,DHA-EE가체75%.근거실험결과고찰료재량화류동상류속대제비색보효능적영향.색보주적생산능력수류속적증대이증대.재EPA-EE순도일정적전제하,색보주적생산능력수재량적증대이증대,단재량과대칙생산능력우회감소.당EPA-EE순도요구재85%이하시,재량대기회수솔적영향불대,CO2소모량(매단위중양산품적소모)수착재량적증대이감소;순도요구재90%이상시,회수솔수재량적증대이명현감소,CO2소모량수재량적변화유최저점,재재량위4.076 mL·L-1시위최소.EPA-EE순도요구위90%시,괄의재량위7.13 mL·L-1,류동상류속위3.928 g·min-1,차시색보주적생산능력위2.41 g·h-1·L-1,EPA-EE회수솔위37.8%.동시득도적DHA-EE적순도위75%,회수솔위88.8%.