浙江大学学报(农业与生命科学版)
浙江大學學報(農業與生命科學版)
절강대학학보(농업여생명과학판)
JOURNAL OF ZHEJIANG UNIVERSITY(AGRICULTURE & LIFE SCIENCES)
2005年
6期
760-764
,共5页
李金页%郑平%吴东雷%周尚兴%丁革胜
李金頁%鄭平%吳東雷%週尚興%丁革勝
리금혈%정평%오동뢰%주상흥%정혁성
味精离交废水%混凝沉淀%硫酸钙%正交试验
味精離交廢水%混凝沉澱%硫痠鈣%正交試驗
미정리교폐수%혼응침정%류산개%정교시험
通过正交试验,系统地考察了多个因素对味精离交废水混凝沉淀除硫的影响,获得了除硫效果达最优水平的组合条件,即原废水的浓度(35.526 g/L),Ca2+投加量为SO42-含量的1.5倍,pH为3.2,不加混凝剂聚丙烯酰胺或聚合氯化铝;确定了混凝沉淀法中各因素对除硫效果的影响程度由大到小依次为:废水浓度、沉淀剂(CaCl2)的投加量、废水pH值、混凝剂的投加方式和投加量.根据原废水中的SO42-浓度等摩尔投加Ca2+(CaCl2),经过15 min后,SO42-去除率达90%,能够满足厌氧生物处理的要求;沉淀过程具有浓悬浮液沉淀的特点,清水区和悬浮物区分界面明显;沉降24 h后生成的沉淀物含水率为81.4%.若将原废水稀释,在同样的条件下,SO42-去除率降低,沉淀物含水率升高,颗粒物沉降性变差,上清液浑浊.故对味精废水的沉淀除硫处理宜在高浓度下进行.
通過正交試驗,繫統地攷察瞭多箇因素對味精離交廢水混凝沉澱除硫的影響,穫得瞭除硫效果達最優水平的組閤條件,即原廢水的濃度(35.526 g/L),Ca2+投加量為SO42-含量的1.5倍,pH為3.2,不加混凝劑聚丙烯酰胺或聚閤氯化鋁;確定瞭混凝沉澱法中各因素對除硫效果的影響程度由大到小依次為:廢水濃度、沉澱劑(CaCl2)的投加量、廢水pH值、混凝劑的投加方式和投加量.根據原廢水中的SO42-濃度等摩爾投加Ca2+(CaCl2),經過15 min後,SO42-去除率達90%,能夠滿足厭氧生物處理的要求;沉澱過程具有濃懸浮液沉澱的特點,清水區和懸浮物區分界麵明顯;沉降24 h後生成的沉澱物含水率為81.4%.若將原廢水稀釋,在同樣的條件下,SO42-去除率降低,沉澱物含水率升高,顆粒物沉降性變差,上清液渾濁.故對味精廢水的沉澱除硫處理宜在高濃度下進行.
통과정교시험,계통지고찰료다개인소대미정리교폐수혼응침정제류적영향,획득료제류효과체최우수평적조합조건,즉원폐수적농도(35.526 g/L),Ca2+투가량위SO42-함량적1.5배,pH위3.2,불가혼응제취병희선알혹취합록화려;학정료혼응침정법중각인소대제류효과적영향정도유대도소의차위:폐수농도、침정제(CaCl2)적투가량、폐수pH치、혼응제적투가방식화투가량.근거원폐수중적SO42-농도등마이투가Ca2+(CaCl2),경과15 min후,SO42-거제솔체90%,능구만족염양생물처리적요구;침정과정구유농현부액침정적특점,청수구화현부물구분계면명현;침강24 h후생성적침정물함수솔위81.4%.약장원폐수희석,재동양적조건하,SO42-거제솔강저,침정물함수솔승고,과립물침강성변차,상청액혼탁.고대미정폐수적침정제류처리의재고농도하진행.