大连工业大学学报
大連工業大學學報
대련공업대학학보
JOURNAL OF DALIAN POLYTECHNIC UNIVERSITY
2009年
6期
433-437
,共5页
庞世红%王承遇%马眷荣%马振珠%张国武%WANG W Pual
龐世紅%王承遇%馬眷榮%馬振珠%張國武%WANG W Pual
방세홍%왕승우%마권영%마진주%장국무%WANG W Pual
自洁玻璃%常压化学气相沉积%光催化%亲水性
自潔玻璃%常壓化學氣相沉積%光催化%親水性
자길파리%상압화학기상침적%광최화%친수성
self-cleaning glass%APCVD%photocatalytic%hydrophilic
利用常压化学气相沉积技术,在浮法玻璃线上制备了TiO2自洁薄膜玻璃.研究了水和氧气对薄膜沉积速率的影响,结果表明水和氧气的加入增加了薄膜的沉积速率.分别用原子力显微镜和X-射线衍射分析仪研究了薄膜的表面形貌和晶型结构,薄膜表面的平均粗糙度为84 nm,其晶型由锐钛矿和金红石组成.同时还研究了自洁玻璃的光催化活性和亲水性,随着紫外光照时间的增加,薄膜的光催化活性增加且对水的接触角由光照前的54°降到光照后的6°.
利用常壓化學氣相沉積技術,在浮法玻璃線上製備瞭TiO2自潔薄膜玻璃.研究瞭水和氧氣對薄膜沉積速率的影響,結果錶明水和氧氣的加入增加瞭薄膜的沉積速率.分彆用原子力顯微鏡和X-射線衍射分析儀研究瞭薄膜的錶麵形貌和晶型結構,薄膜錶麵的平均粗糙度為84 nm,其晶型由銳鈦礦和金紅石組成.同時還研究瞭自潔玻璃的光催化活性和親水性,隨著紫外光照時間的增加,薄膜的光催化活性增加且對水的接觸角由光照前的54°降到光照後的6°.
이용상압화학기상침적기술,재부법파리선상제비료TiO2자길박막파리.연구료수화양기대박막침적속솔적영향,결과표명수화양기적가입증가료박막적침적속솔.분별용원자력현미경화X-사선연사분석의연구료박막적표면형모화정형결구,박막표면적평균조조도위84 nm,기정형유예태광화금홍석조성.동시환연구료자길파리적광최화활성화친수성,수착자외광조시간적증가,박막적광최화활성증가차대수적접촉각유광조전적54°강도광조후적6°.
The self-cleaning glass coated with TiO2 was prepared on a float glass line using on-line deposition technology, in which the titanium dioxide thin films was prepared using the on-line atmospheric pressure chemical vapor deposition (APCVD) method. The introduction of additional water vapor and the oxygen flow could increase the deposition rate to some extent. The studies on the film with atomic force microscope (AFM) and X-ray diffractometer (XRD) showed the surface roughness in about 84 nm and the crystalline structures of anatase and rutile in TiO2 thin film. The photocatalytic and hydrophilic characters of self-cleaning glass were tested using degradation efficiency and the water contact angle. It showed that the degradation efficiency of self-cleaning glass was increased with irradiation time expanded and the water contact angle was decreased rapidly from 54 to 6 degree after irradiated by UV light.