农业工程学报
農業工程學報
농업공정학보
2010年
7期
272-276
,共5页
杜连柱%陈羚%杨鹏%张克强
杜連柱%陳羚%楊鵬%張剋彊
두련주%진령%양붕%장극강
发酵%粪%秸秆%过酸状态%沼液%氨氮
髮酵%糞%秸稈%過痠狀態%沼液%氨氮
발효%분%갈간%과산상태%소액%안담
在沼液回流的条件下,研究猪粪和秸秆固体产酸发酵过程中,不同原料配比(猪粪与秸秆质量比分别为4:1、2:1、1:1、1:3和0:1即纯秸秆)对产酸发酵效果的影响.试验结果表明:增加发酵原料猪粪比例有利于调节发酵体系pH值,但酸化液中氨氮质量浓度较高;沼液回流能有效避免体系过酸现象;上述不同原料质量配比产酸发酵产物以乙酸为主,试验周期内,累积产乙酸质量分别占各反应器挥发性脂肪酸(VFAs)总质量的80.8%、81.8%、77.1%、78.3%和73.8%,酸化液中丙酸质量浓度均低于1.6 g,L,累积产生质量分别占各反应器VFAs总质量的4.8%、2.8%、7.2%、6.5%和8.4%.综合分析表明,猪粪与秸秆比为2:1时,发酵过程中产酸效果优于其他配比试验.
在沼液迴流的條件下,研究豬糞和秸稈固體產痠髮酵過程中,不同原料配比(豬糞與秸稈質量比分彆為4:1、2:1、1:1、1:3和0:1即純秸稈)對產痠髮酵效果的影響.試驗結果錶明:增加髮酵原料豬糞比例有利于調節髮酵體繫pH值,但痠化液中氨氮質量濃度較高;沼液迴流能有效避免體繫過痠現象;上述不同原料質量配比產痠髮酵產物以乙痠為主,試驗週期內,纍積產乙痠質量分彆佔各反應器揮髮性脂肪痠(VFAs)總質量的80.8%、81.8%、77.1%、78.3%和73.8%,痠化液中丙痠質量濃度均低于1.6 g,L,纍積產生質量分彆佔各反應器VFAs總質量的4.8%、2.8%、7.2%、6.5%和8.4%.綜閤分析錶明,豬糞與秸稈比為2:1時,髮酵過程中產痠效果優于其他配比試驗.
재소액회류적조건하,연구저분화갈간고체산산발효과정중,불동원료배비(저분여갈간질량비분별위4:1、2:1、1:1、1:3화0:1즉순갈간)대산산발효효과적영향.시험결과표명:증가발효원료저분비례유리우조절발효체계pH치,단산화액중안담질량농도교고;소액회류능유효피면체계과산현상;상술불동원료질량배비산산발효산물이을산위주,시험주기내,루적산을산질량분별점각반응기휘발성지방산(VFAs)총질량적80.8%、81.8%、77.1%、78.3%화73.8%,산화액중병산질량농도균저우1.6 g,L,루적산생질량분별점각반응기VFAs총질량적4.8%、2.8%、7.2%、6.5%화8.4%.종합분석표명,저분여갈간비위2:1시,발효과정중산산효과우우기타배비시험.