CAJ | 학술논문

以不同的草粪比配制原料,进行厌氧发酵,研究草粪比对甘蔗叶干法厌氧发酵产气效果的影响.结果表明,草粪比为1:1和2:1的处理组产气速度快,有明显的产气高峰,在发酵前40 d就产生了大部分气体.草粪比为1:1的处理组总产气量最高,达到1 218.46 L,甲烷含量稳定后持续25 d保持在60%以上,草粪比为2:1的处理组总产气量849.20 L,甲烷含量持续18 d保持在60%以上,草粪比为1:0的处理组总产气量335.50 L,甲烷含量稳定后保持在45%左右.草粪比为1:1和2:1的处理组总同体产气量相差不大,但明显高于草粪比为1:0的处理组.因此,添加猪粪有利于甘蔗叶干法厌氧发酵的进行,两者混合发酵比单一发酵产气效果要好.在产气高峰之后及时更换物料,可维持较高的产气量以保证实际用气量.
이불동적초분비배제원료,진행염양발효,연구초분비대감자협간법염양발효산기효과적영향.결과표명,초분비위1:1화2:1적처리조산기속도쾌,유명현적산기고봉,재발효전40 d취산생료대부분기체.초분비위1:1적처리조총산기량최고,체도1 218.46 L,갑완함량은정후지속25 d보지재60%이상,초분비위2:1적처리조총산기량849.20 L,갑완함량지속18 d보지재60%이상,초분비위1:0적처리조총산기량335.50 L,갑완함량은정후보지재45%좌우.초분비위1:1화2:1적처리조총동체산기량상차불대,단명현고우초분비위1:0적처리조.인차,첨가저분유리우감자협간법염양발효적진행,량자혼합발효비단일발효산기효과요호.재산기고봉지후급시경환물료,가유지교고적산기량이보증실제용기량.
Preparation of raw materials in accordance with the different mass ratio of pig manure to Sugarcane leaves, effect of different ratios of manure to straw on the gas production were studied. Results showed that the ratio of manure to straw at 1:1 and 2:1 produce gas faster with a obvious peak of gas production , and produced the majority of gas between 40 days after the start. The ratio of manure to straw at 1:1 had the maximal yield, up to 1 218.46 L in 60 days, the methane content remained at over 60% in 25 days. The biogas yield of the ratio of manure to straw at 2:1 was 849.20 L, the methane content remained at over 60% in 18 days. The biogas yield of the ratio of manure to straw at 1:0 was 335.50 L, the methane content remained at about 45%. The biogas yield of Total Solids of 1:1 was no less than 2:1, but obviously higher than 1:0. Therefore, adding pig manure in favor of sugarcane leaves to carry out dry anaerobic fermentation, and the effect of mixed fermentation better than the single fermentation. Replacement of materials after the peak, higher yield can be maintained to ensure that the actual use of gas.