燃烧科学与技术
燃燒科學與技術
연소과학여기술
JOURNAL OF COMBUSTION SCIENCE AND TECHNOLOGY
2010年
1期
92-95
,共4页
辛胜伟%卢啸风%刘汉周%曾兵
辛勝偉%盧嘯風%劉漢週%曾兵
신성위%로소풍%류한주%증병
混烧%煤与污泥%循环流化床%富氧燃烧
混燒%煤與汙泥%循環流化床%富氧燃燒
혼소%매여오니%순배류화상%부양연소
co-combustion%sludge and coal%circulating fluidized bed,CFB%oxygen-enriched combustion
结合污泥的特性与富氧燃烧技术的优点,在一个内径为100 mm的循环流化床焚烧炉内进行煤与污泥的富氧燃烧试验.试验分析了不同煤泥质量比,在氧体积分数为21%~35%环境下的燃烧特性以及送风含氧量、床层温度对烟气成分的影响.结果表明:不同质量比的燃料在不同氧气氛围的燃烧特性不同;当给料量恒定时,随着送风含氧量的增大,总风量减少,炉膛的温度逐渐升高,烟气中SO_2与NO_x浓度都呈增大的趋势,这有利于SO_2与NO_x的脱除;NO_x体积分数随床层温度的升高逐渐增加.
結閤汙泥的特性與富氧燃燒技術的優點,在一箇內徑為100 mm的循環流化床焚燒爐內進行煤與汙泥的富氧燃燒試驗.試驗分析瞭不同煤泥質量比,在氧體積分數為21%~35%環境下的燃燒特性以及送風含氧量、床層溫度對煙氣成分的影響.結果錶明:不同質量比的燃料在不同氧氣氛圍的燃燒特性不同;噹給料量恆定時,隨著送風含氧量的增大,總風量減少,爐膛的溫度逐漸升高,煙氣中SO_2與NO_x濃度都呈增大的趨勢,這有利于SO_2與NO_x的脫除;NO_x體積分數隨床層溫度的升高逐漸增加.
결합오니적특성여부양연소기술적우점,재일개내경위100 mm적순배류화상분소로내진행매여오니적부양연소시험.시험분석료불동매니질량비,재양체적분수위21%~35%배경하적연소특성이급송풍함양량、상층온도대연기성분적영향.결과표명:불동질량비적연료재불동양기분위적연소특성불동;당급료량항정시,수착송풍함양량적증대,총풍량감소,로당적온도축점승고,연기중SO_2여NO_x농도도정증대적추세,저유리우SO_2여NO_x적탈제;NO_x체적분수수상층온도적승고축점증가.
The experimental research on the advantages of oxygen-enriched combustion and the characteristics of sewage sludge was carried out in a CFB incinerator, the diameter of whose furnace is 100 mm. The experimental analysis was made of the combustion characteristics of fuels with different mass rate under the oxygen concentrations of 21%-35%. The further analysis was made of the effects of oxygen content and fluid bed temperature on composition in flue gas. The results show that combustion characteristics vary with different mixing rate between coal and sludge under different oxygen atmosphere. With constant amount of fuel and increase of oxygen content, the total air volume decreases, the furnace temperature increases gradually and SO_2 and NO_x concentrations tend to increase, which is beneficial to the removal of SO_2 and NO_x. NO_x concentration increases gradually as fluid bed temperature increase.