大连理工大学学报
大連理工大學學報
대련리공대학학보
JOURNAL OF DALIAN UNIVERSITY OF TECHNOLOGY
2009年
6期
806-811
,共6页
夏松柏%穆春丰%刘天庆%张庆瑜%陆巧羽%孙相彧
夏鬆柏%穆春豐%劉天慶%張慶瑜%陸巧羽%孫相彧
하송백%목춘봉%류천경%장경유%륙교우%손상욱
滴状冷凝%初始液滴%反应动力学%电子探针%扫描电镜%机理
滴狀冷凝%初始液滴%反應動力學%電子探針%掃描電鏡%機理
적상냉응%초시액적%반응동역학%전자탐침%소묘전경%궤리
dropwise condensation%initial droplet%reaction dynamics%electron probe microanalyzer%scanning electron microscope (SEM)%mechanism
蒸汽在过冷表面进行滴状冷凝时的初始液滴形成机理一直是悬而未决的问题.应用电子探针和扫描电镜两种方法对水蒸气冷凝前后镁表面上化学成分的变化进行了检测,发现冷凝后镁表面上氧含量明显增加,而且随着过冷度和冷凝时间的增加而增加.为了深入分析氧含量的增加是整个表面都反应造成的还是仅局部反应导致的,建立了镁与凝液反应的动力学关系,并推算出初始液滴所占面积分率远小于1的结果.同时电子探针的扫描检测结果证明氧元素在镁表面上的分布是不均匀的,凝液所占面积分率的图像处理结果与动力学计算结果相吻合.因此,初始形成的冷凝液仅在表面的局部区域产生,不是以薄液膜的形武覆盖表面,即滴状冷凝初始液滴的形成机理在纳米尺度下符合固定成核中心假说.
蒸汽在過冷錶麵進行滴狀冷凝時的初始液滴形成機理一直是懸而未決的問題.應用電子探針和掃描電鏡兩種方法對水蒸氣冷凝前後鎂錶麵上化學成分的變化進行瞭檢測,髮現冷凝後鎂錶麵上氧含量明顯增加,而且隨著過冷度和冷凝時間的增加而增加.為瞭深入分析氧含量的增加是整箇錶麵都反應造成的還是僅跼部反應導緻的,建立瞭鎂與凝液反應的動力學關繫,併推算齣初始液滴所佔麵積分率遠小于1的結果.同時電子探針的掃描檢測結果證明氧元素在鎂錶麵上的分佈是不均勻的,凝液所佔麵積分率的圖像處理結果與動力學計算結果相吻閤.因此,初始形成的冷凝液僅在錶麵的跼部區域產生,不是以薄液膜的形武覆蓋錶麵,即滴狀冷凝初始液滴的形成機理在納米呎度下符閤固定成覈中心假說.
증기재과랭표면진행적상냉응시적초시액적형성궤리일직시현이미결적문제.응용전자탐침화소묘전경량충방법대수증기냉응전후미표면상화학성분적변화진행료검측,발현냉응후미표면상양함량명현증가,이차수착과랭도화냉응시간적증가이증가.위료심입분석양함량적증가시정개표면도반응조성적환시부국부반응도치적,건립료미여응액반응적동역학관계,병추산출초시액적소점면적분솔원소우1적결과.동시전자탐침적소묘검측결과증명양원소재미표면상적분포시불균균적,응액소점면적분솔적도상처리결과여동역학계산결과상문합.인차,초시형성적냉응액부재표면적국부구역산생,불시이박액막적형무복개표면,즉적상냉응초시액적적형성궤리재납미척도하부합고정성핵중심가설.
The mechanism of formation of initial droplets for dropwise condensation is still in suspense. An electron probe microanalyzer (EPMA) and scanning electron microscope (SEM) were used to scan the variation of the chemical compositions on the magnesium surfaces before and after the initial condensation. The results show that the oxygen content on the test surfaces increases with subcooling and condensation time obviously after the initial dropwise condensation. In order to further analyze the variation of oxygen content occurring on the whole surface or only at the partial locations, the reaction dynamic relationship of magnesium and condensate was founded. And the calculated result indicates that the area ratio occupied by condensate is less than 1. At the same time, the detected results of EMPA and SEM show that oxygen on the test surface distributes non-uniformly, the area ratios occupied by initial condensate calculated with the reaction dynamic equation agree well with those from the image analysis. Therefore, the initial condensate forms only in partial positions and doesn't cover the whole surface in the form of film. As a result, the mechanism of formation of initial droplets for dropwise condensation accords with the hypothesis of nucleation sites in nano-meter scale.