针织工业
針織工業
침직공업
KNITTING INDUSTRIES
2013年
10期
50-53
,共4页
涤纶织物%分散染料%防紫外线整理%染色%紫外线吸收剂
滌綸織物%分散染料%防紫外線整理%染色%紫外線吸收劑
조륜직물%분산염료%방자외선정리%염색%자외선흡수제
Polyester Fabric%Disperse Dyes%Antiultraviolet Finishing%Dyeing%UV-absorber
采用防紫外线整理剂JLSUN RSCJ-966、Herst RHTUV100分别与分散染料对涤纶织物进行防紫外线整理染色同浴研究，分析了两种紫外线吸收剂对于整理后涤纶针织物的防紫外线性能、耐洗牢度和耐晒牢度的影响，得出二者最佳整理工艺条件。结果表明，当JLSUN RSCJ-966用量为3%或者Herst R HTUV100用量为4%时，整理后织物UPF值均可超过50，水洗40次后织物UPF值仍然超过50，织物的耐晒牢度均提高到5级。
採用防紫外線整理劑JLSUN RSCJ-966、Herst RHTUV100分彆與分散染料對滌綸織物進行防紫外線整理染色同浴研究，分析瞭兩種紫外線吸收劑對于整理後滌綸針織物的防紫外線性能、耐洗牢度和耐曬牢度的影響，得齣二者最佳整理工藝條件。結果錶明，噹JLSUN RSCJ-966用量為3%或者Herst R HTUV100用量為4%時，整理後織物UPF值均可超過50，水洗40次後織物UPF值仍然超過50，織物的耐曬牢度均提高到5級。
채용방자외선정리제JLSUN RSCJ-966、Herst RHTUV100분별여분산염료대조륜직물진행방자외선정리염색동욕연구，분석료량충자외선흡수제대우정리후조륜침직물적방자외선성능、내세뇌도화내쇄뇌도적영향，득출이자최가정리공예조건。결과표명，당JLSUN RSCJ-966용량위3%혹자Herst R HTUV100용량위4%시，정리후직물UPF치균가초과50，수세40차후직물UPF치잉연초과50，직물적내쇄뇌도균제고도5급。
The ultraviolet absorbing agents-JLSUN RSCJ-966 and Herst RHTUV100 are used together with dis-perse dye to finish polyester knitted fabric in one bath. The effect of two ultraviolet absorbers on anti-ultraviolet properties and color fastness to washing, fastness to sunlight are analyzed, and the optimum process conditions are obtained. The results show that: when the dosages of JLSUN RSCJ-966 is 3% or the dosages of Herst RHTUV100 is 4%,UPF of the finished fabric is almost over 50,which keeps unchanged after 40 times of washing. Meanwhile,fast-ness to sunlight of finished fabric is improved to Level five.
