全面腐蚀控制
全麵腐蝕控製
전면부식공제
TOTAL CORROSION CONTROL
2013年
10期
75-79
,共5页
李世勇%张彩霞%张文超%张新发%吴保玉%徐军%陈怀兵
李世勇%張綵霞%張文超%張新髮%吳保玉%徐軍%陳懷兵
리세용%장채하%장문초%장신발%오보옥%서군%진부병
苏里格气田%甲污水预处理%腐蚀速率%除氧剂%阻垢剂
囌裏格氣田%甲汙水預處理%腐蝕速率%除氧劑%阻垢劑
소리격기전%갑오수예처리%부식속솔%제양제%조구제
sulige gas field%methanol wastewater pretreatment%corrosion rate%oxygen scavenger%scale inhibitor
针对苏里格气田某天然气处理厂的高浓度甲醇污水腐蚀现状,室内开发出,油田用除氧剂等。通过现场考察、室内试验及理论分析,对目前处理工艺流程增加除氧剂加药口,并将阻垢剂加药口从过滤器后换至反应沉降罐前,试验结果表明:该技术稳定性好,油田除氧剂现场加药量为0.1%,阻垢剂加药浓度为130mg/L,加药25天后过滤器出口腐蚀速率低至0.038mm/a,在75℃未出现结垢现象,解决了甲醇回收再利用设备的腐蚀和结垢问题,对整个系统起到很好的保护作用。
針對囌裏格氣田某天然氣處理廠的高濃度甲醇汙水腐蝕現狀,室內開髮齣,油田用除氧劑等。通過現場攷察、室內試驗及理論分析,對目前處理工藝流程增加除氧劑加藥口,併將阻垢劑加藥口從過濾器後換至反應沉降罐前,試驗結果錶明:該技術穩定性好,油田除氧劑現場加藥量為0.1%,阻垢劑加藥濃度為130mg/L,加藥25天後過濾器齣口腐蝕速率低至0.038mm/a,在75℃未齣現結垢現象,解決瞭甲醇迴收再利用設備的腐蝕和結垢問題,對整箇繫統起到很好的保護作用。
침대소리격기전모천연기처리엄적고농도갑순오수부식현상,실내개발출,유전용제양제등。통과현장고찰、실내시험급이론분석,대목전처리공예류정증가제양제가약구,병장조구제가약구종과려기후환지반응침강관전,시험결과표명:해기술은정성호,유전제양제현장가약량위0.1%,조구제가약농도위130mg/L,가약25천후과려기출구부식속솔저지0.038mm/a,재75℃미출현결구현상,해결료갑순회수재이용설비적부식화결구문제,대정개계통기도흔호적보호작용。
Aiming at the high concentrations of methanol sewage corrosion Present Situation for a natural gas processing plant in the Sulige gas field, oilfield oxygen scavenger is developed indoor. Through site visits, laboratory experiments and theoretical analysis, the treatment process increases the oxygen scavenger dosing port, and scale inhibitor dosing mouth to feed from the filter after the previous the reaction settling tank. The test results show that good stability of the technique, oilfield deoxidant site dosage is 0.1%, the antiscalant dosing concentration is 130mg/L, the corrosion rate of the dosing outlet of the filter lowers to 0.038mm/a after 25 days, the scaling phenomenon does not appear in the 75°C. Methanol recycling equipment corrosion and scaling problems are resolved, which gives a good protection to the entire system.