浙江农业学报
浙江農業學報
절강농업학보
ACTA AGRICULTURAE ZHEJIANGENSIS
2013年
6期
1378-1382
,共5页
施瀚昱%牟介刚%郑水华%甘建军%林玲%范文粲
施瀚昱%牟介剛%鄭水華%甘建軍%林玲%範文粲
시한욱%모개강%정수화%감건군%림령%범문찬
双蜗壳泵%隔板长度%径向力平衡%数值模拟%静压分布
雙蝸殼泵%隔闆長度%徑嚮力平衡%數值模擬%靜壓分佈
쌍와각빙%격판장도%경향력평형%수치모의%정압분포
double volute pump%baffle length%radial force balance%numerical simulation%static pressure distribution
为探究蜗壳隔板长度对离心泵径向力平衡的影响,以IH-200-150-400型双蜗壳离心泵为研究对象,在5个不同的流量工况点对单蜗壳泵和3种不同隔板长度的双蜗壳泵内部流场进行CFD数值模拟分析。双蜗壳结构方案分别为L1:隔板弧度110°;L2:隔板弧度180°;L3:隔板弧度195°。对模拟结果进行分析表明:双蜗壳泵较单蜗壳泵能较好地平衡径向力,随着双蜗壳泵隔板长度的增加,双蜗壳泵径向力平衡效果有所提高,但效果提升并不明显,当隔板绕叶轮弧度大于180°时,隔板长度对径向力平衡影响非常小;隔板长度取L3是较合理的,在平衡径向力的同时,兼顾了铸造难度;较之单蜗壳泵,双蜗壳泵的效率和扬程有所下降,随着双蜗壳泵隔板长度的增加,泵的效率呈上升趋势,泵的扬程呈下降趋势。
為探究蝸殼隔闆長度對離心泵徑嚮力平衡的影響,以IH-200-150-400型雙蝸殼離心泵為研究對象,在5箇不同的流量工況點對單蝸殼泵和3種不同隔闆長度的雙蝸殼泵內部流場進行CFD數值模擬分析。雙蝸殼結構方案分彆為L1:隔闆弧度110°;L2:隔闆弧度180°;L3:隔闆弧度195°。對模擬結果進行分析錶明:雙蝸殼泵較單蝸殼泵能較好地平衡徑嚮力,隨著雙蝸殼泵隔闆長度的增加,雙蝸殼泵徑嚮力平衡效果有所提高,但效果提升併不明顯,噹隔闆繞葉輪弧度大于180°時,隔闆長度對徑嚮力平衡影響非常小;隔闆長度取L3是較閤理的,在平衡徑嚮力的同時,兼顧瞭鑄造難度;較之單蝸殼泵,雙蝸殼泵的效率和颺程有所下降,隨著雙蝸殼泵隔闆長度的增加,泵的效率呈上升趨勢,泵的颺程呈下降趨勢。
위탐구와각격판장도대리심빙경향력평형적영향,이IH-200-150-400형쌍와각리심빙위연구대상,재5개불동적류량공황점대단와각빙화3충불동격판장도적쌍와각빙내부류장진행CFD수치모의분석。쌍와각결구방안분별위L1:격판호도110°;L2:격판호도180°;L3:격판호도195°。대모의결과진행분석표명:쌍와각빙교단와각빙능교호지평형경향력,수착쌍와각빙격판장도적증가,쌍와각빙경향력평형효과유소제고,단효과제승병불명현,당격판요협륜호도대우180°시,격판장도대경향력평형영향비상소;격판장도취L3시교합리적,재평형경향력적동시,겸고료주조난도;교지단와각빙,쌍와각빙적효솔화양정유소하강,수착쌍와각빙격판장도적증가,빙적효솔정상승추세,빙적양정정하강추세。
In order to clarify the relationship between baffle length of volute and radial force balance , the radial force of single volute pump and double volute pump with three different baffle length was studied in IH -200-150-400 double volute pump at five different operation points based on CFD numerical simulation .The structure scheme of double vo-lute was:L1,baffle radian 110°;L2,baffle radian 180°;L3,baffle radian 195°.The numerical simulation result in-dicated that double volute pump can effectively balance the radial force than single volute pump .With the increase of baffle length, the effect of radial force balance of double volute pump was improved , but the improving effect was not obvious.When baffle radian that around impeller was greater than 180°, baffle length had little influence on radial force balance .It's rational to take L 3 as the baffle length considering the radial force balance and casting difficulty . Compared to the single volute pump , double volute pump had a lower efficiency and pump head .With the increase of baffle length, the efficiency showed an increase trend yet the head showed a decrease trend .