矿产保护与利用
礦產保護與利用
광산보호여이용
CONSERVATION AND UTILIZATION OF MINERAL RESOURCES
2013年
6期
37-41
,共5页
张永康%胡四春%张耀%马化龙
張永康%鬍四春%張耀%馬化龍
장영강%호사춘%장요%마화룡
高铁铝土矿%氧化铝%溶出率
高鐵鋁土礦%氧化鋁%溶齣率
고철려토광%양화려%용출솔
high-iron bauxite%alumina%digestion rate
针对广西某地高铁一水硬铝石型铝土矿的矿物特性,采用拜耳法溶出工艺,对其进行了溶出试验研究。研究结果表明:最佳溶出条件为溶出温度270℃、溶出时间60 min、配料分子比1.45、石灰加入量7%、磨矿细度(-0.097 mm含量)为85%、循环母液苛性碱浓度230 g/L,在此条件下氧化铝的相对溶出率达到95.15%。
針對廣西某地高鐵一水硬鋁石型鋁土礦的礦物特性,採用拜耳法溶齣工藝,對其進行瞭溶齣試驗研究。研究結果錶明:最佳溶齣條件為溶齣溫度270℃、溶齣時間60 min、配料分子比1.45、石灰加入量7%、磨礦細度(-0.097 mm含量)為85%、循環母液苛性堿濃度230 g/L,在此條件下氧化鋁的相對溶齣率達到95.15%。
침대엄서모지고철일수경려석형려토광적광물특성,채용배이법용출공예,대기진행료용출시험연구。연구결과표명:최가용출조건위용출온도270℃、용출시간60 min、배료분자비1.45、석회가입량7%、마광세도(-0.097 mm함량)위85%、순배모액가성감농도230 g/L,재차조건하양화려적상대용출솔체도95.15%。
Based on the characteristics of the high -iron diasporic bauxite from Guangxi ,leaching alumina by Bayer process was carried out .The results showed that the optimum conditions were di-gestion temperature of 270 ℃,digestion time of 60 minutes,caustic ratio of 1.45,lime dosage of 7% to bauxite ,grinding fineness of ore to -0 .097 mm accounted for 85%,caustic alkali concentra-tion of 230 g/L.Under the optimum conditions ,the digestion rate of alumina was 95.15%.