西安交通大学学报
西安交通大學學報
서안교통대학학보
JOURNAL OF XI'AN JIAOTONG UNIVERSITY
2014年
3期
68-71,127
,共5页
陈金锋%吴智敏%冯健美%彭学院
陳金鋒%吳智敏%馮健美%彭學院
진금봉%오지민%풍건미%팽학원
闪蒸气压缩机%闪蒸气回收%低温进气%容积效率
閃蒸氣壓縮機%閃蒸氣迴收%低溫進氣%容積效率
섬증기압축궤%섬증기회수%저온진기%용적효솔
boil-off gas compressor%boil-off gas recovery%low suction temperature%volumetric efficiency
针对低温进气对液化天然气闪蒸气(BOG)压缩机容积效率影响很大的问题,搭建了低温进气压缩机性能测试实验台.通过在气缸不同位置安装温度传感器,测量了不同进气温度下压缩机气缸内气体温度及外壁面温度,采用体积流量计测量了压缩机实际进、排气流量;通过在压缩机进口前的管路上缠加热带,采用并联铜管旁通管路,实现了进气温度调节.根据测量结果对影响容积效率的因素,特别是温度系数和进气系数进行了计算分析,结果表明:BOG压缩机稳定运行时,随着进气温度从-54.2℃降低到-142.2℃,进气系数、温度系数和容积效率均明显减小,分别下降了25.5%、25.0%和23.75%;进气温度为-142.2℃时,气缸外壁面温差达到最大值76℃.该结果可为闪蒸气回收式压缩机气缸设计提供参考.
針對低溫進氣對液化天然氣閃蒸氣(BOG)壓縮機容積效率影響很大的問題,搭建瞭低溫進氣壓縮機性能測試實驗檯.通過在氣缸不同位置安裝溫度傳感器,測量瞭不同進氣溫度下壓縮機氣缸內氣體溫度及外壁麵溫度,採用體積流量計測量瞭壓縮機實際進、排氣流量;通過在壓縮機進口前的管路上纏加熱帶,採用併聯銅管徬通管路,實現瞭進氣溫度調節.根據測量結果對影響容積效率的因素,特彆是溫度繫數和進氣繫數進行瞭計算分析,結果錶明:BOG壓縮機穩定運行時,隨著進氣溫度從-54.2℃降低到-142.2℃,進氣繫數、溫度繫數和容積效率均明顯減小,分彆下降瞭25.5%、25.0%和23.75%;進氣溫度為-142.2℃時,氣缸外壁麵溫差達到最大值76℃.該結果可為閃蒸氣迴收式壓縮機氣缸設計提供參攷.
침대저온진기대액화천연기섬증기(BOG)압축궤용적효솔영향흔대적문제,탑건료저온진기압축궤성능측시실험태.통과재기항불동위치안장온도전감기,측량료불동진기온도하압축궤기항내기체온도급외벽면온도,채용체적류량계측량료압축궤실제진、배기류량;통과재압축궤진구전적관로상전가열대,채용병련동관방통관로,실현료진기온도조절.근거측량결과대영향용적효솔적인소,특별시온도계수화진기계수진행료계산분석,결과표명:BOG압축궤은정운행시,수착진기온도종-54.2℃강저도-142.2℃,진기계수、온도계수화용적효솔균명현감소,분별하강료25.5%、25.0%화23.75%;진기온도위-142.2℃시,기항외벽면온차체도최대치76℃.해결과가위섬증기회수식압축궤기항설계제공삼고.