光学精密工程
光學精密工程
광학정밀공정
OPTICS AND PRECISION ENGINEERING
2014年
4期
942-948
,共7页
赵学良%张承进%顾建军%刘红波%李康
趙學良%張承進%顧建軍%劉紅波%李康
조학량%장승진%고건군%류홍파%리강
压电驱动器%蠕变%台阶电压%起始时间
壓電驅動器%蠕變%檯階電壓%起始時間
압전구동기%연변%태계전압%기시시간
piezoactuator%creep%stair voltage%initial time
研究了具有不同离散化台阶的正弦电压对压电陶瓷驱动器蠕变大小以及蠕变起始时间的影响,采用新的数学模型分析了低频下压电陶瓷驱动器的蠕变特性.首先,对0.025 Hz/0V~ 60 V正弦电压输入信号进行了5种倍数关系的离散化,分析了蠕变与输入电压的关系以及蠕变与输入台阶电压压差的关系.然后,按照提出的数学模型,在符合文中所述两种准则前提下,对蠕变起始时间进行了预测.实验结果表明,上升段蠕变变化范围最大出现在台阶电压等于47.7V时,而下降段蠕变变化范围最大出现在台阶电压等于12.3 V;相比于20个台阶,320个台阶对应的上升段最大蠕变增长量下降了899.5%,而在下降段最大蠕变的这一比值增大到了936.9%.使用所提公式对蠕变起始时间进行预测,得到当台阶电压为12.3 V时,20、40、80、160、320个台阶的蠕变起始时间分别在0.959、0.911、0.813、0.664和0.016 ms以后.蠕变与输入电压以及蠕变与输入台阶电压差值都是迟滞关系,并且台阶蠕变随着台阶数量的增加而减小.不同离散化的电压信号改变了蠕变的起始时间,台阶电压数量越多,蠕变起始时间越早.
研究瞭具有不同離散化檯階的正絃電壓對壓電陶瓷驅動器蠕變大小以及蠕變起始時間的影響,採用新的數學模型分析瞭低頻下壓電陶瓷驅動器的蠕變特性.首先,對0.025 Hz/0V~ 60 V正絃電壓輸入信號進行瞭5種倍數關繫的離散化,分析瞭蠕變與輸入電壓的關繫以及蠕變與輸入檯階電壓壓差的關繫.然後,按照提齣的數學模型,在符閤文中所述兩種準則前提下,對蠕變起始時間進行瞭預測.實驗結果錶明,上升段蠕變變化範圍最大齣現在檯階電壓等于47.7V時,而下降段蠕變變化範圍最大齣現在檯階電壓等于12.3 V;相比于20箇檯階,320箇檯階對應的上升段最大蠕變增長量下降瞭899.5%,而在下降段最大蠕變的這一比值增大到瞭936.9%.使用所提公式對蠕變起始時間進行預測,得到噹檯階電壓為12.3 V時,20、40、80、160、320箇檯階的蠕變起始時間分彆在0.959、0.911、0.813、0.664和0.016 ms以後.蠕變與輸入電壓以及蠕變與輸入檯階電壓差值都是遲滯關繫,併且檯階蠕變隨著檯階數量的增加而減小.不同離散化的電壓信號改變瞭蠕變的起始時間,檯階電壓數量越多,蠕變起始時間越早.
연구료구유불동리산화태계적정현전압대압전도자구동기연변대소이급연변기시시간적영향,채용신적수학모형분석료저빈하압전도자구동기적연변특성.수선,대0.025 Hz/0V~ 60 V정현전압수입신호진행료5충배수관계적리산화,분석료연변여수입전압적관계이급연변여수입태계전압압차적관계.연후,안조제출적수학모형,재부합문중소술량충준칙전제하,대연변기시시간진행료예측.실험결과표명,상승단연변변화범위최대출현재태계전압등우47.7V시,이하강단연변변화범위최대출현재태계전압등우12.3 V;상비우20개태계,320개태계대응적상승단최대연변증장량하강료899.5%,이재하강단최대연변적저일비치증대도료936.9%.사용소제공식대연변기시시간진행예측,득도당태계전압위12.3 V시,20、40、80、160、320개태계적연변기시시간분별재0.959、0.911、0.813、0.664화0.016 ms이후.연변여수입전압이급연변여수입태계전압차치도시지체관계,병차태계연변수착태계수량적증가이감소.불동리산화적전압신호개변료연변적기시시간,태계전압수량월다,연변기시시간월조.