南京林业大学学报(自然科学版)
南京林業大學學報(自然科學版)
남경임업대학학보(자연과학판)
JOURNAL OF NANJING FORESTRY UNIVERSITY(NATURAL SCIENCE EDITION)
2014年
3期
120-124
,共5页
李文定%王超%张洋%高鹏%李珊珊%高晨超
李文定%王超%張洋%高鵬%李珊珊%高晨超
리문정%왕초%장양%고붕%리산산%고신초
胶合板%高频热压%大豆蛋白胶黏剂%胶合性能
膠閤闆%高頻熱壓%大豆蛋白膠黏劑%膠閤性能
효합판%고빈열압%대두단백효점제%효합성능
plywood%radio-frequency heating and pressing%soy protein adhesive%bonding characteristics
采用高频介质加热技术,研究了不同含水率条件下的多层豆胶胶合板板坯温度场分布和水分迁移情况,以及单板涂胶量对豆胶胶合板胶合性能的影响。结果表明:在高频热压(频率为6.78 MHz,压力为1.0 MPa)过程中,板坯内部温度场分布均匀;干燥效率呈现出从表层向芯层逐渐增加,即由里到外的干燥模式;当单板双面涂胶量为400 g/m2时,胶层平均湿态剪切强度为0.83 MPa,高频热压时间仅为12 min。
採用高頻介質加熱技術,研究瞭不同含水率條件下的多層豆膠膠閤闆闆坯溫度場分佈和水分遷移情況,以及單闆塗膠量對豆膠膠閤闆膠閤性能的影響。結果錶明:在高頻熱壓(頻率為6.78 MHz,壓力為1.0 MPa)過程中,闆坯內部溫度場分佈均勻;榦燥效率呈現齣從錶層嚮芯層逐漸增加,即由裏到外的榦燥模式;噹單闆雙麵塗膠量為400 g/m2時,膠層平均濕態剪切彊度為0.83 MPa,高頻熱壓時間僅為12 min。
채용고빈개질가열기술,연구료불동함수솔조건하적다층두효효합판판배온도장분포화수분천이정황,이급단판도효량대두효효합판효합성능적영향。결과표명:재고빈열압(빈솔위6.78 MHz,압력위1.0 MPa)과정중,판배내부온도장분포균균;간조효솔정현출종표층향심층축점증가,즉유리도외적간조모식;당단판쌍면도효량위400 g/m2시,효층평균습태전절강도위0.83 MPa,고빈열압시간부위12 min。
The distribution of temperature field and moisture migration in the mats with different moisture content through radio-frequency ( RF) heating and pressing was investigated in this work, the influence of gluing content of soyprotein adhesive ( SPA) on the bonding characteristics of plywood was also examined. The results showed that the mats had a u-niformly distribution of temperature field during the RF heating at 6.78 MHz and pressing at 1.0 MPa. The RF drying ef-ficiency increased towards the center of the mats, creating the typical drying pattern from inside to outside. When the glue spread amount ( two faces) of veneer was 400 g/m2 , the wet shear strength of plywood was 0.83 MPa and the work-ing time was just 12 min.