CAJ | 학술논문

平房仓充氮储藏晚籼稻谷，先用复合膜对粮堆“五面”密闭，并有效处理工艺孔洞、工作间等漏气部位，利用移动式制氮机组通过四个进气口结合上充下排、下充上排和仓内环流或环流风机强排等工艺向粮堆充氮。近三个月氮气储藏过程中，氮气浓度维持在95％范围，杀虫率达到100％，并能有效防止害虫发生，次年害虫发生时间推迟近一个月；存粮脂肪酸值年变化量低于1．5（KOH）mg／100g，2009年充氮储藏期内脂肪酸值仅增加0．7（KOH）mg／100g；粮温变化趋势与常规储藏基本一致，但试验仓平均粮温偏高1℃～1．5℃，局部最高粮温变化提前近15d。
평방창충담저장만선도곡，선용복합막대량퇴“오면”밀폐，병유효처리공예공동、공작간등루기부위，이용이동식제담궤조통과사개진기구결합상충하배、하충상배화창내배류혹배류풍궤강배등공예향량퇴충담。근삼개월담기저장과정중，담기농도유지재95％범위，살충솔체도100％，병능유효방지해충발생，차년해충발생시간추지근일개월；존량지방산치년변화량저우1．5（KOH）mg／100g，2009년충담저장기내지방산치부증가0．7（KOH）mg／100g；량온변화추세여상규저장기본일치，단시험창평균량온편고1℃～1．5℃，국부최고량온변화제전근15d。
Nitrogen filling storage experiment on ate long-grain nonglutinous paddy, first used complex fihn to seal grain stack in five-sides, dealed with the position that leave out air such as abandoned hole and workshop, then used mobile nitrogen generator through four entrance filling nitrogen into grain stack. There are four methods to filling and releasing nitrogen, which were filling up releasing down, filling down releasing up, recirculation under plastic sheet and filling or releasing forced by recirculation blower. Three months experiment showed that while the nitrogen concentration was kept 95%, the mortality rate of the warehouse pest reached to 100%, and the concentration of the nitrogen can also effectively prevent pest occur, the result show that pest occurred suspend almost one month in the next year. The experiment can also stay fatty acid value of the storage grain, the fatty acid value varied under 1.5 （KOH） mg/100 g , the fatty acid value only increased 0.7 （KOH） mg/100 g in the period of nitrogen filling storage course in 2009. The changed law of grain temperature in experiment warehouse was the same as general storage. While compare to general storage, the average of grain temperature in experiment warehouse was more than 1℃- 1.5℃, the highest temperature reached move up 15 days.