森林工程
森林工程
삼림공정
FOREST ENGINEERING
2012年
2期
18-21,25
,共5页
吴志威%潘一凡%王美玲%周飞
吳誌威%潘一凡%王美玲%週飛
오지위%반일범%왕미령%주비
竹炭%得炭率%氧含量%微观结构
竹炭%得炭率%氧含量%微觀結構
죽탄%득탄솔%양함량%미관결구
bamboo charcoal%char yield%oxygen partial pressure%microstructure
竹材炭化过程中,炭化温度和炭化时间是两个十分重要的工艺参数,同时炉内的氧气含量对竹材炭化也会产生较大影响。通过传感器实时测定并控制炉内氧分压,研究炉内氧含量对竹材炭化的影响。结果表明,随着炉内氧分压增加,得炭率下降。用电子显微镜和能谱仪分析观察竹炭的微观结构和残留物成份,揭示竹炭蜂窝状的微观结构;随着炉内氧分压增加,竹炭孔径变大,表明炭化过程中氧含量影响竹材炭化过程中细胞的收缩。
竹材炭化過程中,炭化溫度和炭化時間是兩箇十分重要的工藝參數,同時爐內的氧氣含量對竹材炭化也會產生較大影響。通過傳感器實時測定併控製爐內氧分壓,研究爐內氧含量對竹材炭化的影響。結果錶明,隨著爐內氧分壓增加,得炭率下降。用電子顯微鏡和能譜儀分析觀察竹炭的微觀結構和殘留物成份,揭示竹炭蜂窩狀的微觀結構;隨著爐內氧分壓增加,竹炭孔徑變大,錶明炭化過程中氧含量影響竹材炭化過程中細胞的收縮。
죽재탄화과정중,탄화온도화탄화시간시량개십분중요적공예삼수,동시로내적양기함량대죽재탄화야회산생교대영향。통과전감기실시측정병공제로내양분압,연구로내양함량대죽재탄화적영향。결과표명,수착로내양분압증가,득탄솔하강。용전자현미경화능보의분석관찰죽탄적미관결구화잔류물성빈,게시죽탄봉와상적미관결구;수착로내양분압증가,죽탄공경변대,표명탄화과정중양함량영향죽재탄화과정중세포적수축。
Carbonization temperature and time are two essential parameters during bamboo carbonization, and the oxygen content in the furnace also has a greater impact on bamboo carbonization. In this paper, the oxygen partial pressure was controlled and tested by measurement sensors in real time. And the impact of furnace oxygen content on bamboo charcoal was studied. Results show that char yield was decreased with the increasing of the oxygen partial pressure in furnace. The microstructure and composition of the bam- boo charcoal were analyzed and observed by field-emission scanning electronic microscope and energy dispersive spectroscopy, which revealed the microscopic structure of bamboo charcoal honeycomb. The average diameter of holes inside of bamboo charcoal becomes larger with the increasing of oxygen partial pressure in furnace, showing that the cell contraction are influenced by the oxygen partial pressure.