弹道学报
彈道學報
탄도학보
JOURNAL OF BALLISTICS
2012年
2期
106-110
,共5页
殷军辉%郑坚%倪新华%潘传增%张炳文
慇軍輝%鄭堅%倪新華%潘傳增%張炳文
은군휘%정견%예신화%반전증%장병문
金属弹带%热软化%再结晶动力学%细观组织%扫描电镜
金屬彈帶%熱軟化%再結晶動力學%細觀組織%掃描電鏡
금속탄대%열연화%재결정동역학%세관조직%소묘전경
metal rotating band%thermal softening%kinetics of recrystallization%mesoscopicorganization%scanning electron microscopy
为研究弹带表层金属在急剧升温条件下的热软化机理与组织演变过程,基于再结晶动力学理论分析表层金属发生再结晶及晶粒长大的可能性,研究了动态再结晶对弹带表层热软化的影响,采用金相显微镜和扫描电镜(SEM)观察并分析了回收砂弹的弹带细观与微观组织.实验中发现了存在于弹带表面薄层的再结晶组织,且部分晶粒未显著长大,这表明再结晶是弹带表层热软化的微观机理.
為研究彈帶錶層金屬在急劇升溫條件下的熱軟化機理與組織縯變過程,基于再結晶動力學理論分析錶層金屬髮生再結晶及晶粒長大的可能性,研究瞭動態再結晶對彈帶錶層熱軟化的影響,採用金相顯微鏡和掃描電鏡(SEM)觀察併分析瞭迴收砂彈的彈帶細觀與微觀組織.實驗中髮現瞭存在于彈帶錶麵薄層的再結晶組織,且部分晶粒未顯著長大,這錶明再結晶是彈帶錶層熱軟化的微觀機理.
위연구탄대표층금속재급극승온조건하적열연화궤리여조직연변과정,기우재결정동역학이론분석표층금속발생재결정급정립장대적가능성,연구료동태재결정대탄대표층열연화적영향,채용금상현미경화소묘전경(SEM)관찰병분석료회수사탄적탄대세관여미관조직.실험중발현료존재우탄대표면박층적재결정조직,차부분정립미현저장대,저표명재결정시탄대표층열연화적미관궤리.
To study the thermal softening mechanism and structure evolution of surface metal under the sharp raise of temperature, kinetics of recrystallization was used to research the possibility of surface metal recrystallization and grains; growth. The effect of dynamic recrystallization on thermal softening of surface metal was analyzed. Mesostructure and microstructure of rotating band were observed by optical microscope and scanning electron microscopy. In experiment, recrystallization structure on surface layer of rotating band was found, and partial grains didn't grow remarkably. The result shows that recrystallization on surface is the microscopic mechanics of thermal softening.