中国煤炭
中國煤炭
중국매탄
CHINA COAL
2014年
5期
93-96
,共4页
任建军%董连平%樊民强%杨宏丽
任建軍%董連平%樊民彊%楊宏麗
임건군%동련평%번민강%양굉려
焦粉%灰分%重选%浮选%工艺流程
焦粉%灰分%重選%浮選%工藝流程
초분%회분%중선%부선%공예류정
coke powder%ash%heavy separation%flotation%technological process
为了实现对高灰焦粉的有效利用,本文针对高灰焦粉进行了重力分选与浮选降灰的试验研究。结果表明,利用旋流重选柱水介质分选0?5~3 mm 焦粉,可以使其灰分从17%降到10?5%以下,产率为80%左右;利用浮选方法分选-0?5 mm 焦粉,可以使其灰分从20%左右降到10?41%,精焦粉产率可达到80?46%,浮选尾矿灰分为60?92%。研究充分证明了利用重选与浮选降低焦粉灰分的可行性,在此基础上提出了对焦粉进行工业分选的工艺流程。
為瞭實現對高灰焦粉的有效利用,本文針對高灰焦粉進行瞭重力分選與浮選降灰的試驗研究。結果錶明,利用鏇流重選柱水介質分選0?5~3 mm 焦粉,可以使其灰分從17%降到10?5%以下,產率為80%左右;利用浮選方法分選-0?5 mm 焦粉,可以使其灰分從20%左右降到10?41%,精焦粉產率可達到80?46%,浮選尾礦灰分為60?92%。研究充分證明瞭利用重選與浮選降低焦粉灰分的可行性,在此基礎上提齣瞭對焦粉進行工業分選的工藝流程。
위료실현대고회초분적유효이용,본문침대고회초분진행료중력분선여부선강회적시험연구。결과표명,이용선류중선주수개질분선0?5~3 mm 초분,가이사기회분종17%강도10?5%이하,산솔위80%좌우;이용부선방법분선-0?5 mm 초분,가이사기회분종20%좌우강도10?41%,정초분산솔가체도80?46%,부선미광회분위60?92%。연구충분증명료이용중선여부선강저초분회분적가행성,재차기출상제출료대초분진행공업분선적공예류정。
In order to achieve effective utilization of highGash coke powder,this paper conG ducted experiments of highGash coke powder by using heavy separation and flotation.The results showed that ash content of 0.5~3 mm coke powder can be reduced from 17% to <10.5% after separated in a cyclone column separator and the yield is about 80%.The ash content of -0.5 mm coke powder can be reduced from 20% to 10.41% after separated by flotation methods,with a clean coke powder yield of 80.46% and tailings ash of 60.92%.The study has fully proved the feaG sibility of reducing the ash content of coke powder using heavy separation and flotation methods. Based on these results,a technological process on industrial separation of coke powder has been proposed.