化工学报
化工學報
화공학보
JOURNAL OF CHEMICAL INDUSY AND ENGINEERING (CHINA)
2013年
6期
2001-2006
,共6页
骆骞%毕勤成%韩彦宁%张巧玲
駱鶱%畢勤成%韓彥寧%張巧玲
락건%필근성%한언저%장교령
降压蒸发%液滴%盐析
降壓蒸髮%液滴%鹽析
강압증발%액적%염석
盐水溶液在降压环境下的蒸发过程的研究,主要集中在海水淡化领域的降膜蒸发过程应用方面和工业制盐方面的平坦表面的蒸发过程的研究.而本文主要集中研究各种实验因素对于液滴温度变化的影响.对于多组分液滴降压环境下相变过程的研究,实验采用浓度为15%和6%的盐水溶液作为一组比较工质,在初始环境压力为94.5~97 kPa,最终环境压力范围为50~3000 Pa,液滴的初始温度范围为7~30℃,初始直径范围为1~3mm的条件下进行实验.通过实验数据分析可知:盐水液滴在降压蒸发过程中的中心温度变化有析盐和不析盐两种现象,随着水分不断地蒸发,当液滴浓度达到22.4%而且温度足够低时就会析出盐分,否则,不会出现析盐现象;同时分析不同浓度、不同最终环境压力、不同初始温度和不同初始直径对液滴相变过程和温度变化的影响,并且观察环境压力降低和液滴温度变化之间的关系.
鹽水溶液在降壓環境下的蒸髮過程的研究,主要集中在海水淡化領域的降膜蒸髮過程應用方麵和工業製鹽方麵的平坦錶麵的蒸髮過程的研究.而本文主要集中研究各種實驗因素對于液滴溫度變化的影響.對于多組分液滴降壓環境下相變過程的研究,實驗採用濃度為15%和6%的鹽水溶液作為一組比較工質,在初始環境壓力為94.5~97 kPa,最終環境壓力範圍為50~3000 Pa,液滴的初始溫度範圍為7~30℃,初始直徑範圍為1~3mm的條件下進行實驗.通過實驗數據分析可知:鹽水液滴在降壓蒸髮過程中的中心溫度變化有析鹽和不析鹽兩種現象,隨著水分不斷地蒸髮,噹液滴濃度達到22.4%而且溫度足夠低時就會析齣鹽分,否則,不會齣現析鹽現象;同時分析不同濃度、不同最終環境壓力、不同初始溫度和不同初始直徑對液滴相變過程和溫度變化的影響,併且觀察環境壓力降低和液滴溫度變化之間的關繫.
염수용액재강압배경하적증발과정적연구,주요집중재해수담화영역적강막증발과정응용방면화공업제염방면적평탄표면적증발과정적연구.이본문주요집중연구각충실험인소대우액적온도변화적영향.대우다조분액적강압배경하상변과정적연구,실험채용농도위15%화6%적염수용액작위일조비교공질,재초시배경압력위94.5~97 kPa,최종배경압력범위위50~3000 Pa,액적적초시온도범위위7~30℃,초시직경범위위1~3mm적조건하진행실험.통과실험수거분석가지:염수액적재강압증발과정중적중심온도변화유석염화불석염량충현상,수착수분불단지증발,당액적농도체도22.4%이차온도족구저시취회석출염분,부칙,불회출현석염현상;동시분석불동농도、불동최종배경압력、불동초시온도화불동초시직경대액적상변과정화온도변화적영향,병차관찰배경압력강저화액적온도변화지간적관계.