浙江科技学院学报
浙江科技學院學報
절강과기학원학보
JOURNAL OF ZHEJIANG UNIVERSITY OF SCIENCE AND TECHNOLOGY
2014年
3期
165-171
,共7页
施红林%黄琦%褚沈佳%库娜娜%俞小燕%王媛媛
施紅林%黃琦%褚瀋佳%庫娜娜%俞小燕%王媛媛
시홍림%황기%저침가%고나나%유소연%왕원원
黄酮%山楂叶%响应面分析法
黃酮%山楂葉%響應麵分析法
황동%산사협%향응면분석법
flavonoids%how thorn leaves%response surface method
响应面分析法优化山楂叶中黄酮的提取工艺,以黄酮粗提取率为指标,采用乙醇回流法提取。通过单因素试验及响应面分析,研究了提取温度、液固比、乙醇体积分数和提取时间4个主要因素对山楂叶中黄酮粗提取率的影响。采用Box-Behnken中心组合设计和响应面分析法,建立了回归方程的预测模型,确定最佳提取条件为液固比29 mL/g ,乙醇体积分数68%,提取温度64℃,提取时间34 min ,在此条件下黄酮粗提取率为3.07%。试验结果与模型预测值基本相符,因此,该工艺可应用于山楂叶中黄酮的提取。
響應麵分析法優化山楂葉中黃酮的提取工藝,以黃酮粗提取率為指標,採用乙醇迴流法提取。通過單因素試驗及響應麵分析,研究瞭提取溫度、液固比、乙醇體積分數和提取時間4箇主要因素對山楂葉中黃酮粗提取率的影響。採用Box-Behnken中心組閤設計和響應麵分析法,建立瞭迴歸方程的預測模型,確定最佳提取條件為液固比29 mL/g ,乙醇體積分數68%,提取溫度64℃,提取時間34 min ,在此條件下黃酮粗提取率為3.07%。試驗結果與模型預測值基本相符,因此,該工藝可應用于山楂葉中黃酮的提取。
향응면분석법우화산사협중황동적제취공예,이황동조제취솔위지표,채용을순회류법제취。통과단인소시험급향응면분석,연구료제취온도、액고비、을순체적분수화제취시간4개주요인소대산사협중황동조제취솔적영향。채용Box-Behnken중심조합설계화향응면분석법,건립료회귀방정적예측모형,학정최가제취조건위액고비29 mL/g ,을순체적분수68%,제취온도64℃,제취시간34 min ,재차조건하황동조제취솔위3.07%。시험결과여모형예측치기본상부,인차,해공예가응용우산사협중황동적제취。
Response surface method was used to optimize the technological conditions of extracting flavonoids compounds from howthorn leaves , with extraction yield of flavonoids as indicator and ethanol reflux as extraction method .Single factor experiment and response surface method were used to discuss the influence on extraction yield by extraction temperature ,liquid-solid ratio ,the ethanol concentration and extraction time .The regression equation prediction model was developed by Box-Behnken center combination design and response surface method .The best extract conditions are as follows:the liquid-solid ratio 29 mL/g ,ethanol concentration 68% ,extracting temperature 64 ℃ and extracting time 34 min .Under the condition ,the extraction yield of flavonoids is 3 .07% .The results are agreed with model predictions . Thus the technology can be used as the extraction process of flavonoids from howthorn leaves .