热力发电
熱力髮電
열력발전
THERMAL POWER GENERATION
2014年
7期
119-123
,共5页
韩中合%李恒凡%严晓哲%钱江波
韓中閤%李恆凡%嚴曉哲%錢江波
한중합%리항범%엄효철%전강파
汽轮机排汽%谐振腔%蒸汽湿度%水膜%积盐
汽輪機排汽%諧振腔%蒸汽濕度%水膜%積鹽
기륜궤배기%해진강%증기습도%수막%적염
exhaust steam%resonant cavity%steam wetness%water film%deposited salt
微波谐振腔法测量蒸汽湿度时,谐振腔内壁面会沉积一层水膜和盐垢,计算在不同水膜和积盐厚度下谐振腔谐振频率的变化,进而分析介质沉积对蒸汽湿度测量的影响.研究结果表明:在水膜或积盐较薄时,其对湿度测量的影响较小,随着沉积介质厚度的增大其影响明显增加;相同水膜厚度时,湿蒸汽压力(温度)对测量结果的影响较小,且随着湿蒸汽压力(温度)的升高,水膜对测量结果的影响略有下降;沉积水膜对测量结果的影响要大于积盐影响,但在用于汽轮机排汽湿度测量时,谐振腔内壁沉积水膜厚度不到35μm,忽略水膜影响引起的湿度测量偏差不到1.262%.
微波諧振腔法測量蒸汽濕度時,諧振腔內壁麵會沉積一層水膜和鹽垢,計算在不同水膜和積鹽厚度下諧振腔諧振頻率的變化,進而分析介質沉積對蒸汽濕度測量的影響.研究結果錶明:在水膜或積鹽較薄時,其對濕度測量的影響較小,隨著沉積介質厚度的增大其影響明顯增加;相同水膜厚度時,濕蒸汽壓力(溫度)對測量結果的影響較小,且隨著濕蒸汽壓力(溫度)的升高,水膜對測量結果的影響略有下降;沉積水膜對測量結果的影響要大于積鹽影響,但在用于汽輪機排汽濕度測量時,諧振腔內壁沉積水膜厚度不到35μm,忽略水膜影響引起的濕度測量偏差不到1.262%.
미파해진강법측량증기습도시,해진강내벽면회침적일층수막화염구,계산재불동수막화적염후도하해진강해진빈솔적변화,진이분석개질침적대증기습도측량적영향.연구결과표명:재수막혹적염교박시,기대습도측량적영향교소,수착침적개질후도적증대기영향명현증가;상동수막후도시,습증기압력(온도)대측량결과적영향교소,차수착습증기압력(온도)적승고,수막대측량결과적영향략유하강;침적수막대측량결과적영향요대우적염영향,단재용우기륜궤배기습도측량시,해진강내벽침적수막후도불도35μm,홀략수막영향인기적습도측량편차불도1.262%.
During steam wetness measurement by microwave resonator,water film and salt will de-posit on the resonant cavity's inner surface.The effect of the deposited dielectric on the resonant frequency was analyzed,and its influence on the steam wetness measurement was also investiga-ted.The results show that:thinner film had less effect on the steam wetness measurement,but this effect aggravated with the film thickness;with the same water film thickness,the wet steam pressure (temperature)had little effects on resonant frequency,and the effect of water film on steam wetness measurement decreased slightly with an increase in wet steam pressure (tempera-ture);the effect of deposited water film on measurement was greater than the deposited salt;how-ever,when this method was applied in the turbine's exhaust wetness measurement,the thickness of water film deposited on the resonator's inner surface was less than 3 5μm,and the deviation of wetness measurement was no more than 1.262%.