化学分析计量
化學分析計量
화학분석계량
CHEMICAL ANALYSIS AND METERAGE
2014年
5期
75-77
,共3页
隋建讯%田立娟%刘克祥%刘彦波%刘萍
隋建訊%田立娟%劉剋祥%劉彥波%劉萍
수건신%전립연%류극상%류언파%류평
酚醛树脂粉%气相色谱法%内标法%六次甲基四胺
酚醛樹脂粉%氣相色譜法%內標法%六次甲基四胺
분철수지분%기상색보법%내표법%륙차갑기사알
phenolic resin powder%gas chromatography%internal standard method%hexamethylenetetramine
以间-甲酚作为内标,建立毛细管气相色谱法测定铸造用酚醛树脂粉中六次甲基四胺的含量。色谱柱为DB-5石英毛细管柱(30 m×0.25 mm,0.25μm),采用FID检测器。用水溶解样品中的六次甲基四胺,经过滤分离后,在确定的色谱条件下进行测定。此方法测定结果的相对标准偏差为0.9%~2.1%(n=6),加标回收率在98.7%~100.2%之间,与HG/T 2755-1996方法测定结果比较,误差在±0.2%之内。该方法灵敏度和准确度均符合要求,方法可靠,可用于铸造用酚醛树脂粉中六次甲基四胺含量的测定。
以間-甲酚作為內標,建立毛細管氣相色譜法測定鑄造用酚醛樹脂粉中六次甲基四胺的含量。色譜柱為DB-5石英毛細管柱(30 m×0.25 mm,0.25μm),採用FID檢測器。用水溶解樣品中的六次甲基四胺,經過濾分離後,在確定的色譜條件下進行測定。此方法測定結果的相對標準偏差為0.9%~2.1%(n=6),加標迴收率在98.7%~100.2%之間,與HG/T 2755-1996方法測定結果比較,誤差在±0.2%之內。該方法靈敏度和準確度均符閤要求,方法可靠,可用于鑄造用酚醛樹脂粉中六次甲基四胺含量的測定。
이간-갑분작위내표,건립모세관기상색보법측정주조용분철수지분중륙차갑기사알적함량。색보주위DB-5석영모세관주(30 m×0.25 mm,0.25μm),채용FID검측기。용수용해양품중적륙차갑기사알,경과려분리후,재학정적색보조건하진행측정。차방법측정결과적상대표준편차위0.9%~2.1%(n=6),가표회수솔재98.7%~100.2%지간,여HG/T 2755-1996방법측정결과비교,오차재±0.2%지내。해방법령민도화준학도균부합요구,방법가고,가용우주조용분철수지분중륙차갑기사알함량적측정。
Using m-cresol as an internal standard, a capillary gas chromatography was developed to determine the content of hexamethylenetetramine in phenolic resin powder for casting use. The chromatographic column was DB-5 silica capillary column (30 m×0.25 mm,0.25μm) with FID detector. Hexamethylenetetramine in sample was dissolved with water, after filtration and separation, hexamethylenetetramine was determined under defined chromatographic conditions. The results showed that the relative standard deviation was 0.9%-2.1%(n=6). The recovery of standard addition was 98.7%-100.2%. The deviation to the result determined by HG/T 2755-1996 method was within ±0.2%. The sensitivity and the accuracy of this method meets the requirement. The method is reliable and can be used to determine the content of hexamethylenetetramine in phenolic resin powder for casting use.