燃料化学学报
燃料化學學報
연료화학학보
JOURNAL OF FUEL CHEMISTRY AND TECHNOLOGY
2014年
10期
1190-1196
,共7页
刘大海%张守玉%涂圣康%金涛%施登宇%裴育峰
劉大海%張守玉%塗聖康%金濤%施登宇%裴育峰
류대해%장수옥%도골강%금도%시등우%배육봉
五彩湾煤%钠%热解%存在形式%变迁
五綵灣煤%鈉%熱解%存在形式%變遷
오채만매%납%열해%존재형식%변천
Wucaiwan coal%sodium%pyrolysis%existence form%transformation
采用不同萃取液进行了新疆准东五彩湾高钠煤萃取实验,并利用微波消解仪和电感耦合等离子体原子发射光谱仪,分析了原煤和不同萃取过程下制得的煤样中的钠元素,确定了五彩湾煤中钠的存在形式。在氮气氛围下进行了原煤及不同萃取过程下煤样的热解实验,分析了热解半焦中钠的存在形式并确定煤中不同存在形式钠在热解过程中的演变规律。结果表明,五彩湾煤中钠主要为水溶钠,有机钠主要以羧酸盐形式存在。450~650℃时,实验煤样热解过程中部分水溶钠和盐酸溶钠会转化为醋酸铵溶钠。在热解过程中,实验煤样中水溶钠和醋酸铵溶钠的析出主要集中于650~850℃,1050℃时则有部分盐酸溶钠析出,此时,在实验条件下钠的挥发达到最大值。煤样半焦中的钠主要以不可溶钠形式存在。
採用不同萃取液進行瞭新疆準東五綵灣高鈉煤萃取實驗,併利用微波消解儀和電感耦閤等離子體原子髮射光譜儀,分析瞭原煤和不同萃取過程下製得的煤樣中的鈉元素,確定瞭五綵灣煤中鈉的存在形式。在氮氣氛圍下進行瞭原煤及不同萃取過程下煤樣的熱解實驗,分析瞭熱解半焦中鈉的存在形式併確定煤中不同存在形式鈉在熱解過程中的縯變規律。結果錶明,五綵灣煤中鈉主要為水溶鈉,有機鈉主要以羧痠鹽形式存在。450~650℃時,實驗煤樣熱解過程中部分水溶鈉和鹽痠溶鈉會轉化為醋痠銨溶鈉。在熱解過程中,實驗煤樣中水溶鈉和醋痠銨溶鈉的析齣主要集中于650~850℃,1050℃時則有部分鹽痠溶鈉析齣,此時,在實驗條件下鈉的揮髮達到最大值。煤樣半焦中的鈉主要以不可溶鈉形式存在。
채용불동췌취액진행료신강준동오채만고납매췌취실험,병이용미파소해의화전감우합등리자체원자발사광보의,분석료원매화불동췌취과정하제득적매양중적납원소,학정료오채만매중납적존재형식。재담기분위하진행료원매급불동췌취과정하매양적열해실험,분석료열해반초중납적존재형식병학정매중불동존재형식납재열해과정중적연변규률。결과표명,오채만매중납주요위수용납,유궤납주요이최산염형식존재。450~650℃시,실험매양열해과정중부분수용납화염산용납회전화위작산안용납。재열해과정중,실험매양중수용납화작산안용납적석출주요집중우650~850℃,1050℃시칙유부분염산용납석출,차시,재실험조건하납적휘발체도최대치。매양반초중적납주요이불가용납형식존재。
The existing forms of sodium in Wucaiwan coal, a high sodium content coal from Zhundong area inXinjiang Uygur Autonomous Regions , China, were determined by three-step-extraction method and by the analysis of microwave digestion and inductively coupled plasma atomic emission spectrometry (ICP-AES). Theexisting forms of sodium in treated samples and the chars were also determined. The transformation of sodium in the raw coal and the treated coals during pyrolysis was investigated. The results show that most of the sodium in Wucaiwan coal exists in the form of water-solution sodium, and the organically bound sodium exists mainly inthe form of carboxylate. During pyrolysis , the release of water soluble sodium and ammonium-acetate soluble sodium from the coal samples mainly takes place in the temperature range of 650 ~ 850 ℃, and the release oftotal sodium gets to the largest value at 1 050 ℃ accompanied with the releasing of hydrochloric soluble sodium. However, most of the sodium in the treated coal chars exists in the form of insoluble type. The transformation ofa part of water soluble sodium and hydrochloric soluble sodium in all samples into ammonium-acetate soluble sodium during pyrolysis at 450 ~ 650 ℃ can be observed.