矿冶工程
礦冶工程
광야공정
2014年
5期
46-49
,共4页
刘青%何亚群%李红%朱向楠%葛林瀚
劉青%何亞群%李紅%硃嚮楠%葛林瀚
류청%하아군%리홍%주향남%갈림한
混合捕收剂%浮选%钛铁尾矿
混閤捕收劑%浮選%鈦鐵尾礦
혼합포수제%부선%태철미광
mixed collectors%flotation%ilmenite tailings
研究了油酸钠、硬脂酸钠和现场混合药剂FH三种捕收剂单独及混合作用于钛铁矿纯矿物、人工混合矿的浮选行为。探究了混合捕收剂对六安钛铁尾矿浮选行为的影响。结果表明:油酸钠与硬脂酸钠混合以及油酸钠与FH混合后浮选效果增强,产生正协同作用,药剂的最佳混合比例分别为7∶3和5∶5。当钛铁矿矿浆浓度为40%,FH/油酸钠混合药剂用量为750 g/t,硫酸用量为1250 g/t时,钛铁矿回收率和品位分别为67.14%和32.60%,相比单独使用两种捕收剂,回收率分别提高了16.89%和8.97%,品位分别提高了11.95%和6.02%。
研究瞭油痠鈉、硬脂痠鈉和現場混閤藥劑FH三種捕收劑單獨及混閤作用于鈦鐵礦純礦物、人工混閤礦的浮選行為。探究瞭混閤捕收劑對六安鈦鐵尾礦浮選行為的影響。結果錶明:油痠鈉與硬脂痠鈉混閤以及油痠鈉與FH混閤後浮選效果增彊,產生正協同作用,藥劑的最佳混閤比例分彆為7∶3和5∶5。噹鈦鐵礦礦漿濃度為40%,FH/油痠鈉混閤藥劑用量為750 g/t,硫痠用量為1250 g/t時,鈦鐵礦迴收率和品位分彆為67.14%和32.60%,相比單獨使用兩種捕收劑,迴收率分彆提高瞭16.89%和8.97%,品位分彆提高瞭11.95%和6.02%。
연구료유산납、경지산납화현장혼합약제FH삼충포수제단독급혼합작용우태철광순광물、인공혼합광적부선행위。탐구료혼합포수제대륙안태철미광부선행위적영향。결과표명:유산납여경지산납혼합이급유산납여FH혼합후부선효과증강,산생정협동작용,약제적최가혼합비례분별위7∶3화5∶5。당태철광광장농도위40%,FH/유산납혼합약제용량위750 g/t,류산용량위1250 g/t시,태철광회수솔화품위분별위67.14%화32.60%,상비단독사용량충포수제,회수솔분별제고료16.89%화8.97%,품위분별제고료11.95%화6.02%。
The flotation behaviors of pure ilmenite mineral and artificial mixed mineral were studied with the presence of single or mixed collectors including sodium oleate, sodium stearate and a mixed collector ( FH) . The effect of mixed collectors on the flotation behavior of the ilmenite tailings was investigated. The results showed that, using a mixture of sodium stearate and sodium oleate, or a mixture of FH and sodium oleate, the flotation efficiency was improved, testifying a positive synergistic effect generated between these collectors, and two kinds of mixed reagents are optimally in the ratio of 7∶3 and 5∶5, respectively. Testing with a pulp density of 40%, dosage of FH?sodium oleate mixture and sulfuric acid at 750 g/t and 1 250 g/t, respectively, resulted in an ilmenite with grade of 32. 60% at a recovery of 67?14%, achieving an increase of 16.89% and 8.97% respectively in recovery, and an increase of 11.95% and 6.02%respectively in grade compared with a separate addition of FH and sodium oleate.