粮食与油脂
糧食與油脂
양식여유지
CEREALS & OILS
2013年
1期
29-31
,共3页
绿豆淀粉%羧甲基淀粉%变性淀粉
綠豆澱粉%羧甲基澱粉%變性澱粉
록두정분%최갑기정분%변성정분
mung bean starch%carboxymethyl starch%modified starch
以绿豆淀粉为原料,一氯乙酸作为醚化剂,乙醇为溶剂,制备羧甲基绿豆淀粉.以20 g绿豆淀粉为基准,采用正交和单因素试验对制备工艺进行优化,探讨氢氧化钠用量、一氯乙酸用量、醚化温度、醚化时间对产品取代度影响.试验结果表明,其最佳制备工艺条件为:氢氧化钠用量(氢氧化钠/淀粉摩尔比)1.3、一氯乙酸用量(一氯乙酸/淀粉摩尔比)1.0、醚化温度52℃、醚化时间120 min;在此条件下,制得羧甲基绿豆淀粉取代度为1.05.
以綠豆澱粉為原料,一氯乙痠作為醚化劑,乙醇為溶劑,製備羧甲基綠豆澱粉.以20 g綠豆澱粉為基準,採用正交和單因素試驗對製備工藝進行優化,探討氫氧化鈉用量、一氯乙痠用量、醚化溫度、醚化時間對產品取代度影響.試驗結果錶明,其最佳製備工藝條件為:氫氧化鈉用量(氫氧化鈉/澱粉摩爾比)1.3、一氯乙痠用量(一氯乙痠/澱粉摩爾比)1.0、醚化溫度52℃、醚化時間120 min;在此條件下,製得羧甲基綠豆澱粉取代度為1.05.
이록두정분위원료,일록을산작위미화제,을순위용제,제비최갑기록두정분.이20 g록두정분위기준,채용정교화단인소시험대제비공예진행우화,탐토경양화납용량、일록을산용량、미화온도、미화시간대산품취대도영향.시험결과표명,기최가제비공예조건위:경양화납용량(경양화납/정분마이비)1.3、일록을산용량(일록을산/정분마이비)1.0、미화온도52℃、미화시간120 min;재차조건하,제득최갑기록두정분취대도위1.05.
Carboxymethyl mung bean starch was synthesized from mung bean starch with chloroacetic acid as the etherifying agent and ethanol as solvent. The process conditions were optimized by single factor test and orthogonal array design methods using 20 g mung bean starch as the criterion and the effects of NaOH content、chloroacetic acid amount、etherification temperature and time on the degree of substitution in carboxymethyl mung bean starch were investigated. The results indicated that the optimal process conditions were as follows:molar ratio of NaOH to starch was 1.3,molar ratio of chloroacetic acid to starch was 1.0,the etherification temperature was 52℃,etherification time was 120 min and carboxymethyl mung bean starch with degree of substitution up to 1.05 was obtained under this synthetic conditions.