中国农业科技导报
中國農業科技導報
중국농업과기도보
REVIEW OF CHINA AGRICULTURAL SCIENCE AND TECHNOLOGY
2013年
1期
152-157
,共6页
陈婕%罗海波*%刘方%陈龙江%苏新建
陳婕%囉海波*%劉方%陳龍江%囌新建
진첩%라해파*%류방%진룡강%소신건
炉渣%钢渣%吸附量%吸磷率
爐渣%鋼渣%吸附量%吸燐率
로사%강사%흡부량%흡린솔
slag%steel slag%adsorption quantity%phosphorus absorption rate
以不同配比的炉渣和钢渣为原料,经混合、成球、焙烧制成炉渣颗粒吸附剂.通过静态吸附试验和动态吸附试验,考察了该吸附剂对沼液中NH +4-N、TN、TP 和COD 的吸附性能.结果表明,沼液的pH、吸附时间、沼液的浓度等因素对不同配比的炉渣颗粒吸附剂吸附沼液中TP 均有显著影响.在适当条件下,不同配比的炉渣颗粒对沼液中的TP 去除率均在90%以上.炉渣颗粒吸附剂对废水中TP 的等温吸附规律可用Langmuir、Freundlich和Temkin模型进行较好的描述.动态吸附试验中废水中NH +4-N、TN、TP、COD去除率均在90%左右,其中以炉渣和钢渣质量比为4∶1(①号)的混合渣去除效果最好,平均去除率分别为99.24%、96.75%、99.94%、89.71%,可达标排放.炉渣颗粒可以作为吸附材料处理沼液中的NH +4-N、TN、TP和COD.
以不同配比的爐渣和鋼渣為原料,經混閤、成毬、焙燒製成爐渣顆粒吸附劑.通過靜態吸附試驗和動態吸附試驗,攷察瞭該吸附劑對沼液中NH +4-N、TN、TP 和COD 的吸附性能.結果錶明,沼液的pH、吸附時間、沼液的濃度等因素對不同配比的爐渣顆粒吸附劑吸附沼液中TP 均有顯著影響.在適噹條件下,不同配比的爐渣顆粒對沼液中的TP 去除率均在90%以上.爐渣顆粒吸附劑對廢水中TP 的等溫吸附規律可用Langmuir、Freundlich和Temkin模型進行較好的描述.動態吸附試驗中廢水中NH +4-N、TN、TP、COD去除率均在90%左右,其中以爐渣和鋼渣質量比為4∶1(①號)的混閤渣去除效果最好,平均去除率分彆為99.24%、96.75%、99.94%、89.71%,可達標排放.爐渣顆粒可以作為吸附材料處理沼液中的NH +4-N、TN、TP和COD.
이불동배비적로사화강사위원료,경혼합、성구、배소제성로사과립흡부제.통과정태흡부시험화동태흡부시험,고찰료해흡부제대소액중NH +4-N、TN、TP 화COD 적흡부성능.결과표명,소액적pH、흡부시간、소액적농도등인소대불동배비적로사과립흡부제흡부소액중TP 균유현저영향.재괄당조건하,불동배비적로사과립대소액중적TP 거제솔균재90%이상.로사과립흡부제대폐수중TP 적등온흡부규률가용Langmuir、Freundlich화Temkin모형진행교호적묘술.동태흡부시험중폐수중NH +4-N、TN、TP、COD거제솔균재90%좌우,기중이로사화강사질량비위4∶1(①호)적혼합사거제효과최호,평균거제솔분별위99.24%、96.75%、99.94%、89.71%,가체표배방.로사과립가이작위흡부재료처리소액중적NH +4-N、TN、TP화COD.
@@@@With different proportion of the slag and blast furnace slag as raw material,slag particles adsorbent was made by mixing raw material into the ball and then roasting the ball. The static and dynamic adsorption test was used to investigate the adsorption performance to biogas slurry of NH +4 -N,TN,TP and COD. The results showed that pH, adsorption time and density of biogas slurry had significant influence on the slag particles adsorbent of different proportion adsorbing biogas slurry TP. Under proper conditions,the biogas slurry TP removal rates of different proportion of slag granules were all over 90% . Langmuir,Freundlich and Temkin models were good descriptions for the isothermal adsorption law of slag particles adsorbent for wastewater TP. The removal rates of NH +4 -N,TN,TP and COD of wastewater in dynamic adsorption test were all around 90% . Among them,the removal effect of No.① mixed slag with slag and steel slag ratio 4∶1 was the best. Its average removal rate reached the discharge standard as 99. 24%,96. 75%,99. 94% and 89. 71%,respectively. Slag particles could be used as adsorption material for treating NH +4 -N,TN,TP and COD.