农业工程学报
農業工程學報
농업공정학보
2014年
22期
209-217
,共9页
程香菊%曾映雪%谢骏%龚望宝
程香菊%曾映雪%謝駿%龔望寶
정향국%증영설%사준%공망보
水处理%水产养殖%氧%微孔曝气%曝气流量%曝气管长度%增氧性能
水處理%水產養殖%氧%微孔曝氣%曝氣流量%曝氣管長度%增氧性能
수처리%수산양식%양%미공폭기%폭기류량%폭기관장도%증양성능
water treatment%aquaculture%oxygen%microporous aeration%diffused air flow rate%aeration tube length%oxygen transfer performance
为了探究曝气流量与曝气管长度对增氧性能的影响,在不同曝气流量、不同曝气管长度条件下进行了室内水体底部微孔曝气增氧试验。分析了曝气流量与曝气管长度对氧体积传质系数、增氧量和氧利用率的影响。研究结果表明,当曝气流量为0.27~0.55 m3/s、曝气管长为0.9~1.5 m时,所对应的氧体积传质系数在0.63~1.1 h-1变化,增氧量在6.8~12.9 g/h变化,氧利用率在6.87%~9.28%变化,且在一定的曝气管长度下,氧体积传质系数、增氧量均与曝气流量成正比,而氧利用率则与其成反比关系;在一定的曝气流量下,曝气管长度对氧体积传质系数产生的影响表现为先高后低再高的趋势;氧体积传质系数与修正的饱和溶解氧浓度是否作为增氧量的主要影响因子取决于曝气管长度;曝气流量对氧利用率较曝气管长度更为敏感。研究还发现,微孔曝气系统中存在着最优曝气管长度,使得增氧性能最佳,并建立了最优曝气管长度与曝气流量、水深、输入压力、最优初始气泡直径的相关关系式,为低碳经济下微孔曝气系统的设计和运行提供了理论依据。
為瞭探究曝氣流量與曝氣管長度對增氧性能的影響,在不同曝氣流量、不同曝氣管長度條件下進行瞭室內水體底部微孔曝氣增氧試驗。分析瞭曝氣流量與曝氣管長度對氧體積傳質繫數、增氧量和氧利用率的影響。研究結果錶明,噹曝氣流量為0.27~0.55 m3/s、曝氣管長為0.9~1.5 m時,所對應的氧體積傳質繫數在0.63~1.1 h-1變化,增氧量在6.8~12.9 g/h變化,氧利用率在6.87%~9.28%變化,且在一定的曝氣管長度下,氧體積傳質繫數、增氧量均與曝氣流量成正比,而氧利用率則與其成反比關繫;在一定的曝氣流量下,曝氣管長度對氧體積傳質繫數產生的影響錶現為先高後低再高的趨勢;氧體積傳質繫數與脩正的飽和溶解氧濃度是否作為增氧量的主要影響因子取決于曝氣管長度;曝氣流量對氧利用率較曝氣管長度更為敏感。研究還髮現,微孔曝氣繫統中存在著最優曝氣管長度,使得增氧性能最佳,併建立瞭最優曝氣管長度與曝氣流量、水深、輸入壓力、最優初始氣泡直徑的相關關繫式,為低碳經濟下微孔曝氣繫統的設計和運行提供瞭理論依據。
위료탐구폭기류량여폭기관장도대증양성능적영향,재불동폭기류량、불동폭기관장도조건하진행료실내수체저부미공폭기증양시험。분석료폭기류량여폭기관장도대양체적전질계수、증양량화양이용솔적영향。연구결과표명,당폭기류량위0.27~0.55 m3/s、폭기관장위0.9~1.5 m시,소대응적양체적전질계수재0.63~1.1 h-1변화,증양량재6.8~12.9 g/h변화,양이용솔재6.87%~9.28%변화,차재일정적폭기관장도하,양체적전질계수、증양량균여폭기류량성정비,이양이용솔칙여기성반비관계;재일정적폭기류량하,폭기관장도대양체적전질계수산생적영향표현위선고후저재고적추세;양체적전질계수여수정적포화용해양농도시부작위증양량적주요영향인자취결우폭기관장도;폭기류량대양이용솔교폭기관장도경위민감。연구환발현,미공폭기계통중존재착최우폭기관장도,사득증양성능최가,병건립료최우폭기관장도여폭기류량、수심、수입압력、최우초시기포직경적상관관계식,위저탄경제하미공폭기계통적설계화운행제공료이론의거。
Microporous aeration systems have become one of the most popular aeration devices used in lakes, reservoirs and aquacultures where there is a need to increase dissolved oxygen concentration. The biggest feature of the microporous aeration aerator is that the initial bubble diameters vary with changes in the aeration tube length, the air flow rate, the submerged water depth, and the input pressure. There are many factors to affect the oxygenation performance, such as the oxygen mass transfer coefficient, oxygen utilization efficiency, and power efficiency. Many researchers consider only the impacts of a single factor or two factors on oxygen transfer performance, without considering the most important keys to affect the oxygenation performance. For this study, the diffused air flow rate and the diffuser tube length were considered the key factors of oxygenation performance to determine the aeration tube length that maximized the oxygenation performance under a given air flow rate. The oxygen mass transfer coefficient, oxygenation rate, and oxygen utilization efficiency were considered the major parameters of the oxygenation performance in this study. To explore the effects of the diffused air flow rate and the diffuser tube length on oxygen transfer performance, after placing a disc made of a coiled, microporous diffuser tube in the middle bottom of an experimental pond, a series of re-oxygenation experiments were conducted under different aeration flow rates and aeration tube lengths. The impact of the aeration flow rate and the diffuser tube length on the oxygen volume mass transfer coefficient, the oxygenation amount and the oxygenation efficiency was analyzed and discussed. The results show that when the aeration air discharge was changed from 0.27 to 0.55 m3/s and the diffuser tube length was changed from 0.9 to 1.5 m, the oxygen mass transfer coefficient increased from 0.63 to 1.1 h-1, the oxygenation rate increased from 6.8 to 12.9 g/h, and the oxygen utilization efficiency increased from 6.87% to 9.28%. Under a given aeration tube length, the oxygen mass transfer coefficient and the oxygenation rate were varied directly with the aeration flow rate;however, the oxygenation efficiency was inversely proportional to the diffused airflow rate. Under a given aeration flow rate, the effects of diffuser tube length on the volumetric mass transfer coefficient produced a trend: the first low to high and then low to high. The oxygen mass transfer coefficient and the saturated dissolved oxygen concentration, which should be the main factors affecting oxygenation efficiency, mainly depend on the aeration tube length. The oxygenation efficiency is more sensitive to the diffused airflow rate than the diffuser tube length. The values of the oxygenation efficiency ranged from 6.87%-9.28%. Some studies have shown that there is an aeration tube length that optimizes the oxygen transfer performance. The simulation was deduced to provide a reference for determining the aeration tube length in actual application. The aeration flow rate and the aeration tube length both have significant impacts on the oxygenation performance. It mainly can be seen that the higher air flow rate, the better oxygenation performance is;in addition, oxygenation performance is very sensitive to aeration tube length. Finally, determining the optimal diffuser tube length not only helps to improve the oxygenation performance but also provides a theoretical basis for the design and operation of microporous aeration systems in a low-carbon economy.