全面腐蚀控制
全麵腐蝕控製
전면부식공제
TOTAL CORROSION CONTROL
2014年
12期
61-64
,共4页
王伟%王鹏%张鹏%张茂伟%刘连河
王偉%王鵬%張鵬%張茂偉%劉連河
왕위%왕붕%장붕%장무위%류련하
活性稀释剂%环氧树脂%粘度%硬度%附着力%抗冲击性能
活性稀釋劑%環氧樹脂%粘度%硬度%附著力%抗遲擊性能
활성희석제%배양수지%점도%경도%부착력%항충격성능
reactive diluent%epoxy resin%viscosity%hardness%adhesion%impact properties
通过在环氧树脂E44/聚醚胺D400体系中引入三种不同结构的活性稀释剂(C12、207和ERD512)，研究了稀释剂对环氧树脂粘度及其固化涂层硬度、附着力和抗冲击性能的影响。结果表明，随着活性稀释剂加入量的提高，环氧树脂粘度和固化涂层的硬度均逐渐降低，附着力先增大后减小；在环氧树脂中加入适量的活性稀释剂，可以提高固化涂层的抗冲击性能，双环氧基活性稀释剂ERD512的增韧效果最明显。
通過在環氧樹脂E44/聚醚胺D400體繫中引入三種不同結構的活性稀釋劑(C12、207和ERD512)，研究瞭稀釋劑對環氧樹脂粘度及其固化塗層硬度、附著力和抗遲擊性能的影響。結果錶明，隨著活性稀釋劑加入量的提高，環氧樹脂粘度和固化塗層的硬度均逐漸降低，附著力先增大後減小；在環氧樹脂中加入適量的活性稀釋劑，可以提高固化塗層的抗遲擊性能，雙環氧基活性稀釋劑ERD512的增韌效果最明顯。
통과재배양수지E44/취미알D400체계중인입삼충불동결구적활성희석제(C12、207화ERD512)，연구료희석제대배양수지점도급기고화도층경도、부착력화항충격성능적영향。결과표명，수착활성희석제가입량적제고，배양수지점도화고화도층적경도균축점강저，부착력선증대후감소；재배양수지중가입괄량적활성희석제，가이제고고화도층적항충격성능，쌍배양기활성희석제ERD512적증인효과최명현。
The influence of reactive diluent on the viscosity, hardness, adhesion and impact properties of epoxy resin are discussed through the addition of three kinds of reactive diluents (C12, 207 and ERD512) in bisphenol A epoxy resinE44-polyether amine D400 system. The research shows that with the increase content of reactive diluent, the viscosity of epoxy resin and the hardness of cured coating decreased, and the adhesion increased at first then decreased. Moreover, the impact property of cured coating was improved by adding proper amount of reactive diluent. Especially, biepoxide reactive diluent 512 showed the optimum toughening effect among the three kinds of reactive diluents above.
