火工品
火工品
화공품
INITIATORS & PYROTECHNICS
2014年
5期
25-27
,共3页
王玉玲%余文力%肖秀友%王涛
王玉玲%餘文力%肖秀友%王濤
왕옥령%여문력%초수우%왕도
高聚物粘结炸药%热老化%尺寸%安定性
高聚物粘結炸藥%熱老化%呎吋%安定性
고취물점결작약%열노화%척촌%안정성
Polymer bonded explosive(PBX)%Heat aging%Dimension%Stability
参照GJB 736.8-1990的试验方法,对HMX基高聚物粘结炸药在71℃高温条件下进行了196d的加速老化试验,并每隔一定时间测定其尺寸。研究发现:随着老化时间的增长,药柱的直径有增大的趋势,但增大速度较慢,其变化量小于0.05%;而药柱的高度和体积在老化前10d急剧减小,而后缓慢减小,当达到某一最小值后又缓慢增大,但总的收缩变化率小于0.9%,小于美军标MIL-STD-1751中1%的要求,说明HMX基高聚物粘结炸药的物理安定性较好。
參照GJB 736.8-1990的試驗方法,對HMX基高聚物粘結炸藥在71℃高溫條件下進行瞭196d的加速老化試驗,併每隔一定時間測定其呎吋。研究髮現:隨著老化時間的增長,藥柱的直徑有增大的趨勢,但增大速度較慢,其變化量小于0.05%;而藥柱的高度和體積在老化前10d急劇減小,而後緩慢減小,噹達到某一最小值後又緩慢增大,但總的收縮變化率小于0.9%,小于美軍標MIL-STD-1751中1%的要求,說明HMX基高聚物粘結炸藥的物理安定性較好。
삼조GJB 736.8-1990적시험방법,대HMX기고취물점결작약재71℃고온조건하진행료196d적가속노화시험,병매격일정시간측정기척촌。연구발현:수착노화시간적증장,약주적직경유증대적추세,단증대속도교만,기변화량소우0.05%;이약주적고도화체적재노화전10d급극감소,이후완만감소,당체도모일최소치후우완만증대,단총적수축변화솔소우0.9%,소우미군표MIL-STD-1751중1%적요구,설명HMX기고취물점결작약적물리안정성교호。
According to experiment method in GJB 736.8-1990,accelerated aging test of one hundred and ninety-six days about PBX based on HMX was done under 71℃, and dimension of grain were measured at a certain time. The study shows that diameter of explosive grain has a increasing trend, but its change is less than 0.05 percent. At the same time, height and volume of explosive grain all declined sharply at the beginning of ten days, then slowly decreased to the lowest value, after that increased slowly again, but total shrinkage rate is less than 0.9 percent, which meet with the requirement of one percent of MIL-STD-1751. This explains that physical properties of explosive are steady.