CAJ | 학술논문

再生水滴灌灌水器堵塞与其内部附生生物膜的形成和生长密切相关，但是生物膜的生长过程对灌水器堵塞加深的影响机制至今还罕有报道。基于此，该文测试了系统累积运行540 h后7种不同堵塞程度灌水器出流及附生生物膜关键组分，并分析灌水器堵塞加深对生物膜组分增长的敏感性。结果表明：灌水器堵塞程度随着附生生物膜组分的增长而加深，两者存在显著的“S型曲线”相关关系（R2＞0.92），呈现出“敏感-微敏感-极度敏感”变化趋势。生物膜固体颗粒物和磷脂脂肪酸含量变化可以极好地刻画这种敏感性的变化过程，说明水源颗粒物和微生物同时是再生水滴灌灌水器堵塞的关键诱发因素。该文的研究可为揭示再生水滴灌灌水器堵塞诱发机理及其推广提供理论依据。
재생수적관관수기도새여기내부부생생물막적형성화생장밀절상관，단시생물막적생장과정대관수기도새가심적영향궤제지금환한유보도。기우차，해문측시료계통루적운행540 h후7충불동도새정도관수기출류급부생생물막관건조분，병분석관수기도새가심대생물막조분증장적민감성。결과표명：관수기도새정도수착부생생물막조분적증장이가심，량자존재현저적“S형곡선”상관관계（R2＞0.92），정현출“민감-미민감-겁도민감”변화추세。생물막고체과립물화린지지방산함량변화가이겁호지각화저충민감성적변화과정，설명수원과립물화미생물동시시재생수적관관수기도새적관건유발인소。해문적연구가위게시재생수적관관수기도새유발궤리급기추엄제공이론의거。
Reclaimed water reused for agriculture has become one of the most effective ways to relieve water shortage and water pollution in China, especially on the North China Plain, and drip irrigation wasbelieved as the most appropriate way to use treated wastewater. Studies have verified that drip irrigation emitter clogging using reclaimed water was closely related to the formation and growing of biofilms those attached inside emitters. However, the exact effects of biofilms components’ increase on drip irrigation emitter clogging were not clear. Besides, the sensibility of emitter clogging degree to the increasing biofilms’ components as the system operated was also unknown. Based on these mentioned above, in this study, based on an on-site drip irrigation emitter clogging experiment using reclaimed water, which was conducted in the wastewater treatment plant, the emitters with seven different clogging degrees of 0, 20%, 35%, 50%, 65%, 80% and 100% were selected to reflect the growing process of biofilm, after the drip irrigation system accumulatively ran for 540 hours, and three kinds of key components (including Solid particles, Phospholipid fatty acids and Extracellular polymeric substances) of biofilms were tested, and then the sensitivity of emitter clogging degree to the increase of biofilms’ components during the whole operating was analyzed. The results showed that drip irrigation emitter clogging became more serious as biofilms’ components increased with the significant “S curve” relationship (R2> 0.92**, significant levela=0.01). Therefore, the sensitivity of emitter clogging degree to the increase of biofilms’ components showed obvious difference in different stages, with the variation trend of “sensitive - micro sensitive - extreme sensitive”. When emitter clogging degree was under 10%-15%, the biofilm growth would obviously enhance emitter clogging, while the formation of biofilms was mainly controlled by the adhesion and proliferation ability of microorganisms and the sticky Extracellular polymeric substances they secreted. However, much less sensitive impact was found when emitter clogging degree was 15%-35%, which was due to the comprehensive influence of the flow velocity in different domains inside emitters and the surface characteristics of growing biofilms. However, minor increase of biofilms’ components would raise emitter clogging degree rapidly since it was above 35%-40%, and then entered the extreme sensitive stage, and the significant increase of emitter clogging degree was caused by the growth-detach-regrowth process of biofilms and microorganisms was stimulated during their growth after adapting to the new environment. In conclusion, the dynamic solid particles and Phospholipid fatty acids increasing characteristics could both describe the mechanisms of biofilm formation and growth inside emitter and affected emitter clogging degree significantly, indicating that both solid particles and microorganisms played the important role in inducing emitter clogging when using reclaimed water drip irrigation. This study aimed at revealing the exact quantitative relationship between biofilms components and emitter clogging degree, in order to find out the most sensitive stage during emitter clogging. The results will provide theoretical reference to reclaimed water drip irrigation emitter clogging mechanism and the application of treated wastewater drip irrigation technology.