铁道学报
鐵道學報
철도학보
2015年
4期
8-16
,共9页
夏超%单希壮%杨志刚%李启良%陈羽
夏超%單希壯%楊誌剛%李啟良%陳羽
하초%단희장%양지강%리계량%진우
地面效应%高速列车%空气动力学%计算流体力学%风洞试验
地麵效應%高速列車%空氣動力學%計算流體力學%風洞試驗
지면효응%고속열차%공기동역학%계산류체역학%풍동시험
ground effect%high-speed train%aerodynamics%CFD%wind tunnel test
本文采用数值模拟方法对高速列车模型风洞试验中存在的地面效应问题进行研究。通过风洞试验验证了数值模拟方法的有效性,利用数值模拟比较了移动地面、静止地面和不同离地间隙工况下,1∶8缩比3节编组高速列车模型的气动力以及模型周围流场的变化规律。研究表明:移动地面较之于静止地面使模型气动阻力增加6.3%,升力减小130%;随着离地间隙的增大,高速列车模型阻力逐渐增大,升力也逐渐增大;不同地面工况下,3节车对气动力变化量的贡献有很大差别。鉴于地面效应会严重影响高速列车模型的气动特性,对风洞试验测量结果带来不可忽视的误差,有必要采用合理的试验手段对其进行消除。其中,采用移动地面法可以很好消除地面效应,而采用抬高模型法不能完全消除地面效应的影响。
本文採用數值模擬方法對高速列車模型風洞試驗中存在的地麵效應問題進行研究。通過風洞試驗驗證瞭數值模擬方法的有效性,利用數值模擬比較瞭移動地麵、靜止地麵和不同離地間隙工況下,1∶8縮比3節編組高速列車模型的氣動力以及模型週圍流場的變化規律。研究錶明:移動地麵較之于靜止地麵使模型氣動阻力增加6.3%,升力減小130%;隨著離地間隙的增大,高速列車模型阻力逐漸增大,升力也逐漸增大;不同地麵工況下,3節車對氣動力變化量的貢獻有很大差彆。鑒于地麵效應會嚴重影響高速列車模型的氣動特性,對風洞試驗測量結果帶來不可忽視的誤差,有必要採用閤理的試驗手段對其進行消除。其中,採用移動地麵法可以很好消除地麵效應,而採用抬高模型法不能完全消除地麵效應的影響。
본문채용수치모의방법대고속열차모형풍동시험중존재적지면효응문제진행연구。통과풍동시험험증료수치모의방법적유효성,이용수치모의비교료이동지면、정지지면화불동리지간극공황하,1∶8축비3절편조고속열차모형적기동력이급모형주위류장적변화규률。연구표명:이동지면교지우정지지면사모형기동조력증가6.3%,승력감소130%;수착리지간극적증대,고속열차모형조력축점증대,승력야축점증대;불동지면공황하,3절차대기동력변화량적공헌유흔대차별。감우지면효응회엄중영향고속열차모형적기동특성,대풍동시험측량결과대래불가홀시적오차,유필요채용합리적시험수단대기진행소제。기중,채용이동지면법가이흔호소제지면효응,이채용태고모형법불능완전소제지면효응적영향。
The paper presented a research about the ground effect during wind tunnel test for high‐speed train model with the CFD numerical simulation method ,which was validated by the wind tunnel test .By numerical simulation ,the conditions of moving ground ,stationary ground and different ground clearances ,were com‐pared to study the variation law of aerodynamic forces and flow field around the 1∶8 scale high speed train model comprising three carriages .The research showed that the aerodynamic drag force of the model increased 6 .3% and the lift force decreased 130% under the moving ground condition ,compared with stationary ground . With the increase of ground clearance ,the drag and lift forces of the high speed train model increased gradual‐ly .Under different ground conditions ,the contribution of the three‐carriage train to variation of aerodynamic force was much different .Given its serious influence on aerodynamics of high speed train model and the non‐negligible error it brought on the results of the wind tunnel test ,it is necessary to take reasonable test measures to eliminate the ground effect in the wind tunnel test .The ground effect can be well eliminated with moving ground method ,w hile it can not be removed completely by raising the model .