环境工程技术学报
環境工程技術學報
배경공정기술학보
JOURNAL OF ENVIR0NMENTAL ENGINEERING TECHNOLOGY
2015年
3期
241-246
,共6页
王红梅%刘宇%王凡%都基峻%张凡%石应杰
王紅梅%劉宇%王凡%都基峻%張凡%石應傑
왕홍매%류우%왕범%도기준%장범%석응걸
水泥工业%废气量%颗粒物%减排
水泥工業%廢氣量%顆粒物%減排
수니공업%폐기량%과립물%감배
cement industry%waste gas volume%particulate matter%emission reduction
水泥工业是颗粒物等大气污染物排放量较大的行业,因排放标准中颗粒物等污染物浓度限值已非常严格,依靠加严标准减排污染物的空间已经越来越小,标准减排难以使水泥工业实现更高的减排目标。水泥生产多个工序会排放废气,在排放标准限值不变的条件下,各类废气的排放总量决定了颗粒物等污染物的排放总量。通过实例分析得出利用窑头余风再循环、减少窑头喂煤一次风比例和分解炉喂煤风机的风量可实现高温废气量的减排,利用窑头窑尾低温废热进行烘干物料可实现低温烘干废气量的减排,将常温废气作为水泥窑窑头和分解炉煤粉的助燃空气可实现常温废气量的减排,进一步分析了通过废气量减排可实现颗粒物等污染物的减排量。
水泥工業是顆粒物等大氣汙染物排放量較大的行業,因排放標準中顆粒物等汙染物濃度限值已非常嚴格,依靠加嚴標準減排汙染物的空間已經越來越小,標準減排難以使水泥工業實現更高的減排目標。水泥生產多箇工序會排放廢氣,在排放標準限值不變的條件下,各類廢氣的排放總量決定瞭顆粒物等汙染物的排放總量。通過實例分析得齣利用窯頭餘風再循環、減少窯頭餵煤一次風比例和分解爐餵煤風機的風量可實現高溫廢氣量的減排,利用窯頭窯尾低溫廢熱進行烘榦物料可實現低溫烘榦廢氣量的減排,將常溫廢氣作為水泥窯窯頭和分解爐煤粉的助燃空氣可實現常溫廢氣量的減排,進一步分析瞭通過廢氣量減排可實現顆粒物等汙染物的減排量。
수니공업시과립물등대기오염물배방량교대적행업,인배방표준중과립물등오염물농도한치이비상엄격,의고가엄표준감배오염물적공간이경월래월소,표준감배난이사수니공업실현경고적감배목표。수니생산다개공서회배방폐기,재배방표준한치불변적조건하,각류폐기적배방총량결정료과립물등오염물적배방총량。통과실례분석득출이용요두여풍재순배、감소요두위매일차풍비례화분해로위매풍궤적풍량가실현고온폐기량적감배,이용요두요미저온폐열진행홍간물료가실현저온홍간폐기량적감배,장상온폐기작위수니요요두화분해로매분적조연공기가실현상온폐기량적감배,진일보분석료통과폐기량감배가실현과립물등오염물적감배량。
Cement industry yields a large air pollution emission including particulate matters.As the particulate concentration limits in the industrial emission standard has been very strict, it leaves smaller and smaller space to further reduce the pollutant emission by setting stricter standard limits.Therefore, the emission reduction by standard has been difficult to make cement industry to achieve a higher reduction target.There are several processes in cement production that emit waste gases.Under the same emission standard limits, the total emissions of various pollutants will be determined by the total waste gas volumes of various kinds.Through case studies, it was shown that the kiln end afterwinds could be recycled to reduce the primary air ratio in kiln end coal feeding and the coal-feeding fan air volume in calcining combustors, so as to realize reduction of high-temperature waste gas volume. The cement kiln end low-temperature waste heat could be used to dry materials and thus realize reduction of waste gas volume in low-temperature drying.The room-temperature exhaust gas could be used as pulverized coal combustion air in cement kiln ends and calcining combustors and thus realize reduction of the room-temperature waste gas volume.The reduction amount of pollutants including particulates through waste gas volume reduction was further analyzed.This research could provide a new way of thinking for cement industry to carry out advanced pollutant emission reduction.