中国有色金属学报(英文版)
中國有色金屬學報(英文版)
중국유색금속학보(영문판)
TRANSACTIONS OF NONFERROUS METALS SOCIETY OF CHINA
2015年
6期
1968-1977
,共10页
张羊换%杨泰%翟亭亭%袁泽明%张国芳%郭世海
張羊換%楊泰%翟亭亭%袁澤明%張國芳%郭世海
장양환%양태%적정정%원택명%장국방%곽세해
贮氢合金%退火处理%相结构%电化学性能%动力学
貯氫閤金%退火處理%相結構%電化學性能%動力學
저경합금%퇴화처리%상결구%전화학성능%동역학
hydrogen storage alloy%annealing treatment%structure%electrochemical performance%kinetics
采用合金熔炼及退火处理的方法制备La?Mg?Ni系 A2B7型La0.8+xMg0.2–xNi3.5(x=0?0.05)电极合金,并研究不同的化学计量比 La/Mg 对该合金的相结构和电化学性能的影响。通过 X 射线衍射(XRD)和扫描电子显微镜(SEM)对合金进行表征。结果表明:合金包含(La, Mg)2Ni7和LaNi5两个主相以及一些残余相LaNi3。随着La/Mg比率的增大,合金中的(La, Mg)2Ni7相含量降低,而LaNi5和LaNi3相的含量升高。La/Mg比的变化也使得合金电极的电化学性能发生显著变化。随着La/Mg比率的增加,铸态及退火态合金的放电容量降低,而循环稳定性明显改善。此外,合金电极的高倍率放电性能(HRD)、电化学阻抗谱(EIS)、Tafel极化曲线以及电势阶跃的测量均表明La/Mg比率的增加提高了合金的电化学动力学性能。
採用閤金鎔煉及退火處理的方法製備La?Mg?Ni繫 A2B7型La0.8+xMg0.2–xNi3.5(x=0?0.05)電極閤金,併研究不同的化學計量比 La/Mg 對該閤金的相結構和電化學性能的影響。通過 X 射線衍射(XRD)和掃描電子顯微鏡(SEM)對閤金進行錶徵。結果錶明:閤金包含(La, Mg)2Ni7和LaNi5兩箇主相以及一些殘餘相LaNi3。隨著La/Mg比率的增大,閤金中的(La, Mg)2Ni7相含量降低,而LaNi5和LaNi3相的含量升高。La/Mg比的變化也使得閤金電極的電化學性能髮生顯著變化。隨著La/Mg比率的增加,鑄態及退火態閤金的放電容量降低,而循環穩定性明顯改善。此外,閤金電極的高倍率放電性能(HRD)、電化學阻抗譜(EIS)、Tafel極化麯線以及電勢階躍的測量均錶明La/Mg比率的增加提高瞭閤金的電化學動力學性能。
채용합금용련급퇴화처리적방법제비La?Mg?Ni계 A2B7형La0.8+xMg0.2–xNi3.5(x=0?0.05)전겁합금,병연구불동적화학계량비 La/Mg 대해합금적상결구화전화학성능적영향。통과 X 사선연사(XRD)화소묘전자현미경(SEM)대합금진행표정。결과표명:합금포함(La, Mg)2Ni7화LaNi5량개주상이급일사잔여상LaNi3。수착La/Mg비솔적증대,합금중적(La, Mg)2Ni7상함량강저,이LaNi5화LaNi3상적함량승고。La/Mg비적변화야사득합금전겁적전화학성능발생현저변화。수착La/Mg비솔적증가,주태급퇴화태합금적방전용량강저,이순배은정성명현개선。차외,합금전겁적고배솔방전성능(HRD)、전화학조항보(EIS)、Tafel겁화곡선이급전세계약적측량균표명La/Mg비솔적증가제고료합금적전화학동역학성능。
In order to investigate the influences of the stoichiometric ratio of La/Mg (increasing La and decreasing Mg on the same mole ratio) on the structure and electrochemical performances of the La?Mg?Ni-based A2B7-type electrode alloy, the as-cast and the annealed ternary La0.8+xMg0.2–xNi3.5 (x=0?0.05) electrode alloys were prepared. The characterization of electrode alloys by X-ray diffraction (XRD) and scanning electron microscopy (SEM) shows that all the as-cast and the annealed alloys hold two major phases of (La,Mg)2Ni7 and LaNi5 as well as a residual phase of LaNi3. Moreover, the increase of La/Mg ratio brings on a decline of (La,Mg)2Ni7 phase and a rise of LaNi5 and LaNi3 phases. The variation of La/Mg ratio gives rise to an evident change of the electrochemical performances of the alloys. The discharge capacities of the as-cast and the annealed alloys evidently decrease with growing the La/Mg ratio, while the cycle stabilities of the alloys visibly augment under the same condition. Furthermore, the high rate discharge ability (HRD), the electrochemical impedance spectrum (EIS), the Tafel polarization curves, and the potential step measurements all indicate that the electrochemical kinetic properties of the alloy electrodes increase with the La/Mg ratio rising.