车用发动机
車用髮動機
차용발동궤
2015年
4期
37-42
,共6页
姜伟%王建军%洪伟%李小平%王新超%解方喜
薑偉%王建軍%洪偉%李小平%王新超%解方喜
강위%왕건군%홍위%리소평%왕신초%해방희
甲醇发动机%废气再循环%分层%燃烧
甲醇髮動機%廢氣再循環%分層%燃燒
갑순발동궤%폐기재순배%분층%연소
methanol engine%EGR%stratification%combustion
针对一台具有螺旋进气道的点火式甲醇发动机 ,采用进气道加装EGR管的方式实现了EGR和新鲜充量的分开引入.应用CFD仿真软件Fire模拟了不同EGR通入时间、不同燃烧室凹坑形状等对EGR分层的影响.结果显示 ,加装EGR管能够实现EGR的分层 ,EGR的通入时长和燃烧室凹坑形状都对EGR的分层产生影响.当燃烧室凹坑形状为浅圆柱型、新鲜充量的通入压力为100 kPa、EGR通入压力为160 kPa时 ,在300°BTDC(压缩上止点前)停止通入 ,能够形成火花塞周围EGR浓度低、越远离燃烧室顶部EGR浓度越高的EGR分层结构.同时 ,在保证EGR率和燃油消耗量相同条件下 ,通过改变点火提前角 ,分析分层EGR和均质EGR对甲醇发动机缸内燃烧的影响.分层EGR能有效地提高缸压峰值、缩短燃烧滞燃期、提前燃烧始点 ,有利于发动机缸内燃烧的改善.
針對一檯具有螺鏇進氣道的點火式甲醇髮動機 ,採用進氣道加裝EGR管的方式實現瞭EGR和新鮮充量的分開引入.應用CFD倣真軟件Fire模擬瞭不同EGR通入時間、不同燃燒室凹坑形狀等對EGR分層的影響.結果顯示 ,加裝EGR管能夠實現EGR的分層 ,EGR的通入時長和燃燒室凹坑形狀都對EGR的分層產生影響.噹燃燒室凹坑形狀為淺圓柱型、新鮮充量的通入壓力為100 kPa、EGR通入壓力為160 kPa時 ,在300°BTDC(壓縮上止點前)停止通入 ,能夠形成火花塞週圍EGR濃度低、越遠離燃燒室頂部EGR濃度越高的EGR分層結構.同時 ,在保證EGR率和燃油消耗量相同條件下 ,通過改變點火提前角 ,分析分層EGR和均質EGR對甲醇髮動機缸內燃燒的影響.分層EGR能有效地提高缸壓峰值、縮短燃燒滯燃期、提前燃燒始點 ,有利于髮動機缸內燃燒的改善.
침대일태구유라선진기도적점화식갑순발동궤 ,채용진기도가장EGR관적방식실현료EGR화신선충량적분개인입.응용CFD방진연건Fire모의료불동EGR통입시간、불동연소실요갱형상등대EGR분층적영향.결과현시 ,가장EGR관능구실현EGR적분층 ,EGR적통입시장화연소실요갱형상도대EGR적분층산생영향.당연소실요갱형상위천원주형、신선충량적통입압력위100 kPa、EGR통입압력위160 kPa시 ,재300°BTDC(압축상지점전)정지통입 ,능구형성화화새주위EGR농도저、월원리연소실정부EGR농도월고적EGR분층결구.동시 ,재보증EGR솔화연유소모량상동조건하 ,통과개변점화제전각 ,분석분층EGR화균질EGR대갑순발동궤항내연소적영향.분층EGR능유효지제고항압봉치、축단연소체연기、제전연소시점 ,유리우발동궤항내연소적개선.
Separate introduction of the recycling exhaust and fresh charge of a spark ignition methanol engine was realized by installing an EGR tube in the helical intake port .The effects of different EGR access times and different combustion chamber pit shapes on EGR stratification were simulated with the CFD FIRE software .The results show that the addition of EGR tube can realize the EGR stratification and the EGR access time and the combustion chamber pit shape have significant effect on EGR stratification .The stratification of low EGR concentration around the spark plug and higher EGR concentration far from com-bustion chamber top is formed when the combustion chamber pit shows shallow cylinder shape ,the pressures of fresh charge and EGR are 100 kPa and 160 kPa respectively and the recirculation finished at 300° BTDC .The influence of stratified EGR and homogeneous EGR on in-cylinder combustion of methanol engine is analyzed based on the same EGR ratio and fuel consump-tion .The stratified EGR can improve the peak cylinder pressure ,shorten the combustion delay period and advance the combus-tion starting point effectively and is useful to improve the in-cylinder combustion of methanol engine .