混凝土与水泥制品
混凝土與水泥製品
혼응토여수니제품
China Concrete and Cement Products
2015年
9期
68-71
,共4页
王宁%张凯峰%赵世冉%姚源%邓天明
王寧%張凱峰%趙世冉%姚源%鄧天明
왕저%장개봉%조세염%요원%산천명
消泡剂%新拌砂浆%流动性%含气量%黏度%屈服应力
消泡劑%新拌砂漿%流動性%含氣量%黏度%屈服應力
소포제%신반사장%류동성%함기량%점도%굴복응력
Defoamers%Flesh mortar%Fluidity%Air content%Viscosity%Yield stress
在聚羧酸系高效减水剂中复配消泡剂,探讨了消泡剂掺量对砂浆性能的影响。结果表明:当基准砂浆加入消泡剂时,基准砂浆的含气量大幅度降低;砂浆处于高流动度状态时,增加消泡剂掺量,砂浆的流动度逐渐增大、含气量逐渐降低且最终趋于稳定、黏度逐渐降低、屈服应力呈现先减后增的趋势,当消泡剂掺量为0.5g时,屈服应力达到最小;固定配比时,增加水胶比,砂浆含气量呈现升高的趋势。
在聚羧痠繫高效減水劑中複配消泡劑,探討瞭消泡劑摻量對砂漿性能的影響。結果錶明:噹基準砂漿加入消泡劑時,基準砂漿的含氣量大幅度降低;砂漿處于高流動度狀態時,增加消泡劑摻量,砂漿的流動度逐漸增大、含氣量逐漸降低且最終趨于穩定、黏度逐漸降低、屈服應力呈現先減後增的趨勢,噹消泡劑摻量為0.5g時,屈服應力達到最小;固定配比時,增加水膠比,砂漿含氣量呈現升高的趨勢。
재취최산계고효감수제중복배소포제,탐토료소포제참량대사장성능적영향。결과표명:당기준사장가입소포제시,기준사장적함기량대폭도강저;사장처우고류동도상태시,증가소포제참량,사장적류동도축점증대、함기량축점강저차최종추우은정、점도축점강저、굴복응력정현선감후증적추세,당소포제참량위0.5g시,굴복응력체도최소;고정배비시,증가수효비,사장함기량정현승고적추세。
Effects of defoamer dosage on properties of mortars were investigated by adding defoamers into the polycar-boxylate superplasticizer. The experimental results show that: when adding defoamer in the reference mortar, the air con-tent of the mortar could decrease sharply; when the mortar is in a high state of fluidity, with the increase of defoamer dosage, the fluidity of mortar increases gradually, the air content of mortar reduces gradually and eventually tends to stabi-lize, the viscosity of mortars could reduce gradually, and the yield stress of mortar presents a trend of decreasing at first and then raising, when the defoamer dosage is 0.5g, the yield stress of mortar reaches a minimum value;when the W/B in-creases, the air content of mortar tends to increase at a fixed mix proportion.