西安工业大学学报
西安工業大學學報
서안공업대학학보
Journal of Xi'an Technological University
2015年
8期
635-641
,共7页
径向引入%多并联分支管%流量分配特性%分配不均匀性
徑嚮引入%多併聯分支管%流量分配特性%分配不均勻性
경향인입%다병련분지관%류량분배특성%분배불균균성
radial-turret-injection%parallel multi-branch%flow distribution characteristics%distribution inhomogeneity
研究了双纵向引入多分支并联管水平集箱系统分支管中流量的分配特性.实验以空气-水混合物为工质,在定温和水平压力为0.11~0.13 MPa 过程下完成.在3个液体流速及每个液体流速对应6个不同的气体流速的实验工况下,测量了所有分支管均在等压降的条件下的空气和水的出口折算流速.实验结果表明:改变进口气体和液体折算流速时,分支管中的气体和液体流速发生显著变化,进口气体和液体流速对分支管中的流量分布有显著影响.在固定进口液体流速时,进口气体流速增大对液体在并联分支管中的分配影响不大,其分配不均性缓慢减小;对气体在并联分支管中的分配不均匀性影响较液体大,气体的分配不均匀性增大.
研究瞭雙縱嚮引入多分支併聯管水平集箱繫統分支管中流量的分配特性.實驗以空氣-水混閤物為工質,在定溫和水平壓力為0.11~0.13 MPa 過程下完成.在3箇液體流速及每箇液體流速對應6箇不同的氣體流速的實驗工況下,測量瞭所有分支管均在等壓降的條件下的空氣和水的齣口摺算流速.實驗結果錶明:改變進口氣體和液體摺算流速時,分支管中的氣體和液體流速髮生顯著變化,進口氣體和液體流速對分支管中的流量分佈有顯著影響.在固定進口液體流速時,進口氣體流速增大對液體在併聯分支管中的分配影響不大,其分配不均性緩慢減小;對氣體在併聯分支管中的分配不均勻性影響較液體大,氣體的分配不均勻性增大.
연구료쌍종향인입다분지병련관수평집상계통분지관중류량적분배특성.실험이공기-수혼합물위공질,재정온화수평압력위0.11~0.13 MPa 과정하완성.재3개액체류속급매개액체류속대응6개불동적기체류속적실험공황하,측량료소유분지관균재등압강적조건하적공기화수적출구절산류속.실험결과표명:개변진구기체화액체절산류속시,분지관중적기체화액체류속발생현저변화,진구기체화액체류속대분지관중적류량분포유현저영향.재고정진구액체류속시,진구기체류속증대대액체재병련분지관중적분배영향불대,기분배불균성완만감소;대기체재병련분지관중적분배불균균성영향교액체대,기체적분배불균균성증대.
An experimental investigation was conducted to study the two-phase distribution in a horizontal header with two inlet turrets and multi outlet branches.Tests were performed using air-liquid mixtures at room temperature and a nominal pressure which ranged form 0.11 ~ 0.13 MPa.The test matrix included three inlet liquid rates and six different inlet gas rates for each liquid rate.The outlet flow superficial velocity of air and water were measured in all branches under the condition of equal pressure drop across all branches.The data showed that there is significant variation in air and water flow rates among the branches ,with changing inlet gas flow rate and inlet liquid flow superficial velocity.The flow distribution among the branches was found to be strongly influenced by the inlet flow superficial velocity of gas and liquid.In the fixed inlet liquid velocity,the inlet gas flow rate increases with little influence on the distribution of the liquid in parallel,and the distribution is slow to reduce. The inlet gas flow rate increases with more influence on the distribution of the gas in parallel than liquid,the gas distribution increases.