福州大学学报(自然科学版)
福州大學學報(自然科學版)
복주대학학보(자연과학판)
Journal of Fuzhou University (Natural Science Edition)
2015年
5期
696-701
,共6页
历福强%蔡丽英%赵素英%陈坤雄%吴丹
歷福彊%蔡麗英%趙素英%陳坤雄%吳丹
력복강%채려영%조소영%진곤웅%오단
膨润土%不饱和脂肪酸%聚合%路易斯酸
膨潤土%不飽和脂肪痠%聚閤%路易斯痠
팽윤토%불포화지방산%취합%로역사산
bentonite%unsaturated fatty acid%polymerization%Lewis acid
以棉籽油酸为反应原料,膨润土、碳酸锂分别为催化剂和助催化剂,在240℃下反应4 h,研究在棉籽油酸二聚反应中不同膨润土的结构和组成对其催化性能的影响.结果表明,不同膨润土的比表面积和孔隙度差别较大,但二者不是影响其催化性能的主要因素.而膨润土晶体的层间距和表面酸性对其产率影响较大,实验中二聚酸产率最大为70.26%,最小为43.58%,原因可能是较大的层间距可以提供较充足的反应空间,有利于体积较大的二聚产物分子的生成,亦有利于其从层状结构中扩散出来.另一方面, xL/xB的摩尔比值越大催化性能越好,原因可能是路易斯酸中心在不饱和脂肪酸的聚合反应中起到关键作用.三种膨润土xAl/xSi的摩尔比值在0.216~0.239之间,差别较小,其对反应的影响较小.
以棉籽油痠為反應原料,膨潤土、碳痠鋰分彆為催化劑和助催化劑,在240℃下反應4 h,研究在棉籽油痠二聚反應中不同膨潤土的結構和組成對其催化性能的影響.結果錶明,不同膨潤土的比錶麵積和孔隙度差彆較大,但二者不是影響其催化性能的主要因素.而膨潤土晶體的層間距和錶麵痠性對其產率影響較大,實驗中二聚痠產率最大為70.26%,最小為43.58%,原因可能是較大的層間距可以提供較充足的反應空間,有利于體積較大的二聚產物分子的生成,亦有利于其從層狀結構中擴散齣來.另一方麵, xL/xB的摩爾比值越大催化性能越好,原因可能是路易斯痠中心在不飽和脂肪痠的聚閤反應中起到關鍵作用.三種膨潤土xAl/xSi的摩爾比值在0.216~0.239之間,差彆較小,其對反應的影響較小.
이면자유산위반응원료,팽윤토、탄산리분별위최화제화조최화제,재240℃하반응4 h,연구재면자유산이취반응중불동팽윤토적결구화조성대기최화성능적영향.결과표명,불동팽윤토적비표면적화공극도차별교대,단이자불시영향기최화성능적주요인소.이팽윤토정체적층간거화표면산성대기산솔영향교대,실험중이취산산솔최대위70.26%,최소위43.58%,원인가능시교대적층간거가이제공교충족적반응공간,유리우체적교대적이취산물분자적생성,역유리우기종층상결구중확산출래.령일방면, xL/xB적마이비치월대최화성능월호,원인가능시로역사산중심재불포화지방산적취합반응중기도관건작용.삼충팽윤토xAl/xSi적마이비치재0.216~0.239지간,차별교소,기대반응적영향교소.
Cottonseed oleic acid were taken as raw materials , bentonite and lithium carbonate as the catalyst and cocatalyst , reaction at 240℃for 4 h .The influence of the structure and composite of dif-ferent bentonites on the catalytic performance was investigated in the dimerization of the cottonseed oil acid.The results showed that the difference of the specific surface area and the porosity of different bentonites were comparatively large .But they were not the leading factor that influenced their catalytic properties.The layer spacing of the bentonite crystal and its surfacial acidity had an important effect on its yield .In the experiment , the maximum yield of the dimer acid is 70 .26%, the minimum is 43.58%.The reason may be larger interlayer spacing can provide more adequate reaction space which is conducive to the generation of large volumes of dimeric molecules and help the product spread from the layered structure .In addition the catalytic properties was increased with the high molar ratio of the Lewis acid to the Br?nsted acid .The reason may be the L acid site plays a key role in the unsaturated fatty acid polymerization.The Al /Si molar ratio of three kinds of bentonite range from 0.216 to 0.239, so the difference is small .It has a small effect on the reaction .