光谱学与光谱分析
光譜學與光譜分析
광보학여광보분석
Spectroscopy and Spectral Analysis
2015年
10期
2740-2745
,共6页
陈彬%武宏阳%韩超%颜欢%刘阁
陳彬%武宏暘%韓超%顏歡%劉閣
진빈%무굉양%한초%안환%류각
微量水分%中红外光谱%绝缘油%电气性能
微量水分%中紅外光譜%絕緣油%電氣性能
미량수분%중홍외광보%절연유%전기성능
Trace water%Mid-infrared spectrum%Insulating oil%Electrical properties
微量水分对绝缘油的介质损耗因数、电阻率等电气性能指标有明显的影响,探讨绝缘油受微量水分的影响规律,对于采取有效措施监控绝缘油的运行状态具有重要意义。首先对配制不同微水含量的绝缘油经过超声波振荡8 h后再进行显微图像观察,得到该油水分散系中游离水和乳化水相对均匀程度在25 m in内其分散状态较为稳定;在此基础上对油水分散系的介质损耗因数、电阻率指标进行了实验测试,得到了微水对绝缘油的电气性能指标的影响规律;然后对不同微水含量的绝缘油进行中红外光谱分析,得到不同微水含量的绝缘油在1640,3400,3450,3615 cm -1波数处的吸光度值。结合绝缘油中红外光谱分析的吸光度值变化以及实验测试结果表明油样在1640,3400,3450,3615 cm-1水分的特征波数处吸光度值数据随水分含量不同而产生明显变化,且吸光度值与水分含量的皮尔逊相关系数分别为0.9641,0.9848,0.9845,0.9440,油样中水分在相应特征波数处的吸光度值能够较好的反映出油样中水分含量的变化趋势;微水对绝缘油介质损耗因数的影响和水分子在3400和3450 cm-1特征波数处的吸光度值变化趋势之间的相关系数较大,分别为0.8606和0.8636;微水对绝缘油介质损耗因数的影响和水分子在1640和3615 cm -1特征波数处的吸光度值变化趋势之间的相关系数分别为-0.9315和-0.9680,从而为绝缘油中微水的监测奠定了前期研究基础。
微量水分對絕緣油的介質損耗因數、電阻率等電氣性能指標有明顯的影響,探討絕緣油受微量水分的影響規律,對于採取有效措施鑑控絕緣油的運行狀態具有重要意義。首先對配製不同微水含量的絕緣油經過超聲波振盪8 h後再進行顯微圖像觀察,得到該油水分散繫中遊離水和乳化水相對均勻程度在25 m in內其分散狀態較為穩定;在此基礎上對油水分散繫的介質損耗因數、電阻率指標進行瞭實驗測試,得到瞭微水對絕緣油的電氣性能指標的影響規律;然後對不同微水含量的絕緣油進行中紅外光譜分析,得到不同微水含量的絕緣油在1640,3400,3450,3615 cm -1波數處的吸光度值。結閤絕緣油中紅外光譜分析的吸光度值變化以及實驗測試結果錶明油樣在1640,3400,3450,3615 cm-1水分的特徵波數處吸光度值數據隨水分含量不同而產生明顯變化,且吸光度值與水分含量的皮爾遜相關繫數分彆為0.9641,0.9848,0.9845,0.9440,油樣中水分在相應特徵波數處的吸光度值能夠較好的反映齣油樣中水分含量的變化趨勢;微水對絕緣油介質損耗因數的影響和水分子在3400和3450 cm-1特徵波數處的吸光度值變化趨勢之間的相關繫數較大,分彆為0.8606和0.8636;微水對絕緣油介質損耗因數的影響和水分子在1640和3615 cm -1特徵波數處的吸光度值變化趨勢之間的相關繫數分彆為-0.9315和-0.9680,從而為絕緣油中微水的鑑測奠定瞭前期研究基礎。
미량수분대절연유적개질손모인수、전조솔등전기성능지표유명현적영향,탐토절연유수미량수분적영향규률,대우채취유효조시감공절연유적운행상태구유중요의의。수선대배제불동미수함량적절연유경과초성파진탕8 h후재진행현미도상관찰,득도해유수분산계중유리수화유화수상대균균정도재25 m in내기분산상태교위은정;재차기출상대유수분산계적개질손모인수、전조솔지표진행료실험측시,득도료미수대절연유적전기성능지표적영향규률;연후대불동미수함량적절연유진행중홍외광보분석,득도불동미수함량적절연유재1640,3400,3450,3615 cm -1파수처적흡광도치。결합절연유중홍외광보분석적흡광도치변화이급실험측시결과표명유양재1640,3400,3450,3615 cm-1수분적특정파수처흡광도치수거수수분함량불동이산생명현변화,차흡광도치여수분함량적피이손상관계수분별위0.9641,0.9848,0.9845,0.9440,유양중수분재상응특정파수처적흡광도치능구교호적반영출유양중수분함량적변화추세;미수대절연유개질손모인수적영향화수분자재3400화3450 cm-1특정파수처적흡광도치변화추세지간적상관계수교대,분별위0.8606화0.8636;미수대절연유개질손모인수적영향화수분자재1640화3615 cm -1특정파수처적흡광도치변화추세지간적상관계수분별위-0.9315화-0.9680,종이위절연유중미수적감측전정료전기연구기출。
Trace water has a significant impact on the electrical performances of the insulating oil ,such as the dielectric loss fac‐tor ,resistivity .So there is an important significance to investigate the influence of insulating oil by trace water ,and monitor its operating status with effective measures .First ,it is necessary to prepare the insulating oil samples with different water content and treat them 8 hours with ultrasonic oscillator ,and observe microscopic images about the water‐oil mixtures in order to study their relative uniformity and stable time ,in the way it can be concluded that the relative uniformity can be kept favorable during the 25 min stable time for free water and emulsification water in oil;Based on this conclusion ,the dielectric loss factor ,resistivi‐ty were tested and the electrical performances of insulating oil with different water content in oil can obtained by analyzing these data;Then ,the absorbance value of the different water content in oil at the spectral wave number of 1 640 ,3 400 ,3 450 ,3 615 cm -1 ,with the mid‐infrared spectral scanning and analyzing to the different water content in oil ,Therefore ,combined the water absorbance values by the mid‐infrared spectral scanning and analyzing with the experimental data of dielectric loss factor value , resistivity value of oil samples .The results shows that the absorbance value of the different water content in oil has a significant difference at the spectral wave number of 1 640 ,3 400 ,3450 ,3 615 cm-1 ,their correlation coefficient are 0.964 1 ,0.984 8 , 0.984 5 ,0.944 0 between the absorbance value and water content at the spectral wave number of 1 640 ,3 400 ,3 450 ,3 615 cm -1 ,it can be obtained that the absorbance value of sample of moisture in the corresponding characteristic wave number can better reflect the change trend of water content ;there is the highly relative of water absorbance values at the spectral wave num‐ber of 3 400 and 3 450 cm -1 with the trends of oil dielectric loss factor values ,their correlation coefficient are 0.860 6 ,0.863 6 ;and relative of water absorbance values at the spectral wave number of 1 640 and 3 615 cm -1 with the trends of oil resistivity val‐ues ,their correlation coefficient is -0.931 5 and -0.968 0 ,this result can be lay the foundation research for monitoring the trace water in oil .